Napoleon Grills PRO 500 manual

Page 14

14

Burner: The burner is made from heavy wall 304 stainless steel, but extreme heat and a corrosive environ- ment can cause surface corrosion to occur. This can be removed with a brass wire brush.

CAUTION! Beware of Spiders.

Spiders and insects are attracted to the smell of propane and natural gas. The burner is equipped with an insect screen on the air shutter, which reduces the likelihood of insects building nests inside the burner but does not entirely eliminate the problem. A nest or web can cause the burner to burn with a soft yellow or orange flame or cause a fire (flashback) at the air shutter underneath the control panel. To clean the inside of the burner, it must be removed from the gas grill: Remove the screw (s) that attaches the burner to the back wall. Slide the burner back and up wards to remove. Cleaning: Use a flexible venturi tube brush to clean the inside of the burner. Shake any loose debris from the burner through the gas inlet. Check the burner ports and valve orifices for blockages. Burner ports can close over time due to cooking debris and corrosion, use an opened paperclip or the supplied port maintenance bit to clean them. Drill out blocked ports using this drill bit in a small cordless drill. The ports are easier to clean if the burner is removed from the grill, but it can also be done with the burner installed. Do not flex the drill bit when drilling the ports, as this will cause the drill bit to break. This drill is for burner ports only, not for the brass orifices (jets) which regulate the flow into the burner. Take care not to enlarge the holes. Ensure the insect screen is clean, tight, and free of any lint or other debris.

Reinstallation: Reverse the procedure to reinstall the burner. Check that the valve enters the burner when installing. Replace sear plate mount and / or tighten screws to complete reinstallation.

WARNING! When reinstalling the burner after cleaning it is very important that the valve/orifice enters the burner tube before lighting your gas grill. If the valve is not inside the burner tube a fire or explosion could occur.

www.napoleongrills.com

Image 14
Contents PRO If YOU Smell GASNapoleon GAS Grill PRESIDENT’S Limited Lifetime Warranty Safe Operating Practices Dimensions Gas Hook-Up Instructions Propane Cylinder SpecificationsGeneral Information Page Leak Testing Instructions Lighting Instructions Cooking Instructions Replacement Screen N565-0002 Infrared Grilling Chart Infrared HeatCleaning Instructions Maintenance Instructions Page Replacement Screen N565-0002 Troubleshooting Problem Possible Causes SolutionPressure to equalize. See lighting instructions Record information here for easy reference Ordering Replacement PartsWarranty Information Avertissement Garantie À VIE Limitée DU Président Conditions Et LimitationsPratiques Sécuritaires D’utilisation Dimensions Spécifications Pour La Bonbonne De Propane Information GénéraleInstructions De Branchement Du Gaz Avertissement Test De Détection De Fuites Instruction D’allumage FermezInstructions D’opération Écrans de rechange N565-0002 Chaleur Infrarouge Tableau de cuisson à l’infrarougeNettoyage Instructions D’entretien Pour ajuster le volet d’airÉcrans de rechange N565-0002 Problème Causes possibles Solutions Guide De DépannageLa peinture semble Accumulation de graisse sur les Inscrivez l’information ici pour y avoir accès facilement Commande De Pièces De RechangeInformation Sur La Garantie Getting Started Pour CommencerN570-0086 #14 x 1/2 810mm Propane Only Propane Seulement Propane Only N570-0086 #14 x 1/2 Disposable grease tray jetable du récipient à graisse N570-0086 #14 x 1/2 810mm N430-0002 N570-0038 1/4-20 X 1/2 810mm N105-0015 Page AVERTISSEMENT! Ne serrez pas 500RSIB N715-0093 N520-0035 N305-0085 Rotisserie Kit Assembly Instruction Instructions D’assemblage De L’ensemble De RôtissoireN160-0002 Page Leak Testing Instructions Test De Détection De Fuites Parts List / Liste DES Pièces PRO500RB Description 500RB Parts List / Liste DES Pièces PRO500RB Parts Diagram / Liste DES Pièces PRO500RB Parts List / Liste DES Pièces PRO500RSIB Parts List / Liste DES Pièces PRO500RSIB Standard Propane units only Compris Parts Diagram / Liste DES Pièces PRO500RSIB Accessories & Parts Order Form BON DE Commande Pour PIÈCES/ACCESSOIRES N415-0248