Desa CDCFPRA WARNING If you smell gas Shut off gas supply, Do not try to light any appliance

Page 31

WARNING: If you smell gas

TROUBLESHOOTING

Continued

WARNING: If you smell gas

•Shut off gas supply.

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the ﬁre department.

IMPORTANT: Operating ﬁreplace where impurities in air exist may create odors. Cleaning supplies, paint, paint remover, cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors. These odors will disappear over time.

OBSERVED PROBLEM POSSIBLE CAUSE

REMEDY

Fireplace produces unwanted 1.	Fireplace burning vapors from
odors	paint, hair spray, glues, clean-
	ers, chemicals, new carpet,
	etc. (See IMPORTANT state-
	ment above)
2.	Low fuel supply (propane/LP
	only)
3.	Gas leak. See Warning state-
	ment at top of page

1.Open window to ventilate room. Stop using odor caus- ing products while ﬁreplace is running

2.Reﬁll supply tank (propane/LP only)

3.Locate and correct all leaks (see Checking Gas Connec- tions, page 17)

Fireplace shuts off in use (ODS	1. Not enough fresh air is avail-		1.	Open window and/or door for
operates)		able		ventilation
	2.	Low line pressure	2.	Contact local natural or pro-
	3.	ODS/pilot is partially		pane/LP gas company
	3.	ODS/pilot is partially	3.	Clean ODS/pilot (see Cleaning
		clogged		and Maintenance, page 26)

Gas odor even when control	1. Gas leak. See Warning state-		1.	Locate and correct all leaks
knob is in OFF position		ment at top of page		(see Checking Gas Connec-
	2.	Control valve defective		tions, page 17)
			2.	Replace control valve

Gas odor during combustion	1. Foreign matter between con-		1.	Take apart gas tubing and
		trol valve and burner		remove foreign matter
	2.	Gas leak. See Warning state-	2.	Locate and correct all leaks
		ment at top of page		(see Checking Gas Connec-
				tions, page 17)

116658-01A

www.desatech.com

31

Image 31

Contents WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance 116658-01A TABLE OF CONTENTSDANGER Carbon monoxide poisoning may lead to death SAFETY INFORMATIONWARNING Any change to this ﬁreplace or its controls can be dangerous Continued CONTROL ACCESSORIESSee Accessories, page OPTIONAL REMOTEﬁreplace. This prevents exces diagrams or failure to use onlySAFETY PILOT WARNING Always haveUnusually Tight Construction b. weather stripping has been added on openable windows and doors andPROVIDING ADEQUATE VENTILATION Figure 3 - Assembling HoodConﬁned and Unconﬁned Space DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATIONDetermining if You Have a Conﬁned or Unconﬁned Space VENTILATION AIR WARNING Never install the ﬁreplace in a bedroom or bathroomin a recreational vehicle as a ﬁreplace insert in high trafﬁc areas in windy or drafty areasCHECK GAS TYPE INSTALLATION ITEMSBefore installing ﬁreplace, make sure you have the items listed below external regulator supplied by installer, for propane/LP units onlyFigure 7 - Rough Opening for Installing in Wall CAUTION If you install the ﬁreplace in a home garagelocate ﬁreplace where moving vehicle will not hit it BUILT-IN FIREPLACE INSTALLATIONFigure 9 - Attaching Fireplace to Wall Studs Note A qualiﬁed installer should make all electri- cal connections4. If you have not installed hood, follow instruc- tions on page 7. Bend four nailing ﬂanges on outer casing with pliers see Figureof the following raise the mantel to an accept- able height OPTIONAL MANTEL INSTALLATIONremove the mantel Figure 12 - Attaching Brass Trim to Fireplace INSTALLING OPTIONAL BLOWER ACCESSORY GA3450TAFigure 13 - Assembling Brass Trim Screw Figure 16 - Installing Switch Plate to Remote/Blower Bracket Installing Blower AccessoryCAUTION Verify proper op- eration after servicing Figure 17 - Installing Blower Bracket Assembly For Built-In InstallationFigure 18 - Wiring Diagram For Blower Accessory Built-In Installation CONNECTING TO GAS SUPPLY external to unit, for leaks after installing or servicing. CorrectWARNING Test all gas piping and connections, internal andFigure 25 - Checking Gas Joints Natural Gas Only PRESSURE TESTING GAS SUPPLY PIPING SYSTEMPRESSURE TESTING FIREPLACE GAS CONNECTIONS Figure 24 - Checking Gas Joints Propane/LP OnlyOPTIONAL WALL MOUNTED THERMOSTAT - GWMT1 OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIESFigure 26 - Disconnecting Wires From Control Valve Figure 28 - Installing Remote Receiver1. Remove jumper wire from control valve see Figure 26, page 7. Install the base onto the wall with the provided screwsFigure 30 - Connecting Wire Terminals “W” and “R” OPTIONAL WALL SWITCH - GWMS2Figure 34 - Installing Side Brick Liners Figure 33 - Installing Rear Brick LinerFigure 35 - Installing Log Figure 36 - Installing ScreenOPERATING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTINGLIGHTING INSTRUCTIONS OPTIONAL HAND-HELD REMOTE OPERATION MANUAL LIGHTING PROCEDURE2. If Using Optional Hand-Held Remote TO TURN OFF GAS TO APPLIANCE4. Press the POWER and LOCK buttons together to turn off the ﬁreplace Figure 40 - Setting the Selector SwitchControl Knob and Flame Adjustment Knob for Remote Operation 3. Press the POWER and LOCK buttons together to turn off the ﬁreplacePILOT FLAME PATTERN OPTIONAL GWMS2 WALL MOUNTED SWITCHsee Troubleshooting, page OPTIONAL GWMT1 WALL MOUNTED THERMOSTATBURNER INJECTOR HOLDER AND PILOT AIR INLET HOLE WARNING Turn off ﬁreplace and let cool before cleaningCONTINUED BURNER FLAME PATTERNFigure 49 - Pilot Inlet Air Hole Natural Gas LOG SETCABINET Figure 48 - Pilot Inlet Air Hole Propane/LP GasREMEDY TROUBLESHOOTINGOBSERVED PROBLEM POSSIBLE CAUSEOBSERVED PROBLEM POSSIBLE CAUSE see Cleaning and Mainte Do not try to light any appliance WARNING If you smell gas Shut off gas supplyIf you cannot reach your gas supplier, call the ﬁre department CDCFNRA SPECIFICATIONSRemote-Ready Models CDCFPRAPARTS UNDER WARRANTY REPLACEMENT PARTSSERVICE HINTS TECHNICAL SERVICEFIREBOX CDCFNRA PARTSBREAKDOWN ILLUSTRATED MODELSFIREBOX MODELS CDCFNRA, CDCFPRA PARTS LISTNatural ILLUSTRATED PARTS BREAKDOWNGas Only REMOTE-READY MODELS BRASS TRIM KIT - GA6095 NOTICE All accessories may not be available for all ﬁreplace modelsTHERMOSTAT-CONTROLLED BLOWER KIT GA3450TA EQUIPMENT SHUTOFF VALVE GA5010RECEIVER AND HAND-HELD REMOTE CONTROL KIT - HRC100 AND HRC1011 CLEANING KIT - GCK/CCKWALL-MOUNT THERMOSTAT SWITCH GWMT1 WALL-MOUNT ON/OFF SWITCH GWMS2NOT A UPC 116658-01 Rev. A 04/05 2701 Industrial Drive P.O. Box116658