Desa CDCFNRA Illustrated Parts Breakdown, Remote-Ready Models Cdcfnra And Cdcfpra, Natural

Page 36

ILLUSTRATED PARTS BREAKDOWN

REMOTE-READY MODELS

CDCFNRA AND CDCFPRA

	9
1	2
1
	6	3
	6
	7
	8	5
9		5
9
10
		9

12 14

	21	Natural
		Gas Only

20		22	15	16

	O
NO	FF
T

www.desatech.com

116658-01A

Image 36

Contents WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance TABLE OF CONTENTS 116658-01ASAFETY INFORMATION DANGER Carbon monoxide poisoning may lead to deathWARNING Any change to this ﬁreplace or its controls can be dangerous CONTROL ACCESSORIES See Accessories, pageOPTIONAL REMOTE Continueddiagrams or failure to use only SAFETY PILOTWARNING Always have ﬁreplace. This prevents excesb. weather stripping has been added on openable windows and doors and PROVIDING ADEQUATE VENTILATIONFigure 3 - Assembling Hood Unusually Tight ConstructionDETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATION Conﬁned and Unconﬁned SpaceDetermining if You Have a Conﬁned or Unconﬁned Space WARNING Never install the ﬁreplace in a bedroom or bathroom in a recreational vehicleas a ﬁreplace insert in high trafﬁc areas in windy or drafty areas VENTILATION AIRINSTALLATION ITEMS Before installing ﬁreplace, make sure you have the items listed belowexternal regulator supplied by installer, for propane/LP units only CHECK GAS TYPECAUTION If you install the ﬁreplace in a home garage locate ﬁreplace where moving vehicle will not hit itBUILT-IN FIREPLACE INSTALLATION Figure 7 - Rough Opening for Installing in WallNote A qualiﬁed installer should make all electri- cal connections 4. If you have not installed hood, follow instruc- tions on page7. Bend four nailing ﬂanges on outer casing with pliers see Figure Figure 9 - Attaching Fireplace to Wall StudsOPTIONAL MANTEL INSTALLATION of the following raise the mantel to an accept- able heightremove the mantel INSTALLING OPTIONAL BLOWER ACCESSORY GA3450TA Figure 12 - Attaching Brass Trim to FireplaceFigure 13 - Assembling Brass Trim Installing Blower Accessory Screw Figure 16 - Installing Switch Plate to Remote/Blower BracketCAUTION Verify proper op- eration after servicing For Built-In Installation Figure 17 - Installing Blower Bracket AssemblyFigure 18 - Wiring Diagram For Blower Accessory Built-In Installation CONNECTING TO GAS SUPPLY installing or servicing. Correct WARNING Test all gas pipingand connections, internal and external to unit, for leaks afterPRESSURE TESTING GAS SUPPLY PIPING SYSTEM PRESSURE TESTING FIREPLACE GAS CONNECTIONSFigure 24 - Checking Gas Joints Propane/LP Only Figure 25 - Checking Gas Joints Natural Gas OnlyOPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIES Figure 26 - Disconnecting Wires From Control ValveFigure 28 - Installing Remote Receiver OPTIONAL WALL MOUNTED THERMOSTAT - GWMT17. Install the base onto the wall with the provided screws Figure 30 - Connecting Wire Terminals“W” and “R” OPTIONAL WALL SWITCH - GWMS2 1. Remove jumper wire from control valve see Figure 26, pageFigure 33 - Installing Rear Brick Liner Figure 35 - Installing LogFigure 36 - Installing Screen Figure 34 - Installing Side Brick LinersFOR YOUR SAFETY READ BEFORE LIGHTING OPERATING FIREPLACELIGHTING INSTRUCTIONS MANUAL LIGHTING PROCEDURE 2. If Using Optional Hand-Held RemoteTO TURN OFF GAS TO APPLIANCE OPTIONAL HAND-HELD REMOTE OPERATIONFigure 40 - Setting the Selector Switch Control Knob and Flame Adjustment Knob for Remote Operation3. Press the POWER and LOCK buttons together to turn off the ﬁreplace 4. Press the POWER and LOCK buttons together to turn off the ﬁreplaceOPTIONAL GWMS2 WALL MOUNTED SWITCH see Troubleshooting, pageOPTIONAL GWMT1 WALL MOUNTED THERMOSTAT PILOT FLAME PATTERNWARNING Turn off ﬁreplace and let cool before cleaning CONTINUEDBURNER FLAME PATTERN BURNER INJECTOR HOLDER AND PILOT AIR INLET HOLELOG SET CABINETFigure 48 - Pilot Inlet Air Hole Propane/LP Gas Figure 49 - Pilot Inlet Air Hole Natural GasTROUBLESHOOTING OBSERVED PROBLEMPOSSIBLE CAUSE REMEDYOBSERVED PROBLEM POSSIBLE CAUSE see Cleaning and Mainte WARNING If you smell gas Shut off gas supply Do not try to light any applianceIf you cannot reach your gas supplier, call the ﬁre department SPECIFICATIONS Remote-Ready ModelsCDCFPRA CDCFNRAREPLACEMENT PARTS SERVICE HINTSTECHNICAL SERVICE PARTS UNDER WARRANTYPARTS BREAKDOWNILLUSTRATED MODELS FIREBOX CDCFNRAPARTS LIST FIREBOX MODELS CDCFNRA, CDCFPRAILLUSTRATED PARTS BREAKDOWN NaturalGas Only REMOTE-READY MODELS NOTICE All accessories may not be available for all ﬁreplace models THERMOSTAT-CONTROLLED BLOWER KIT GA3450TAEQUIPMENT SHUTOFF VALVE GA5010 BRASS TRIM KIT - GA6095CLEANING KIT - GCK/CCK WALL-MOUNT THERMOSTAT SWITCH GWMT1WALL-MOUNT ON/OFF SWITCH GWMS2 RECEIVER AND HAND-HELD REMOTE CONTROL KIT - HRC100 AND HRC10112701 Industrial Drive P.O. Box NOT A UPC 116658-01 Rev. A 04/05116658