Brinkmann CHARCOAL SMOKER CHARCOAL GRILL owner manual Cooking Grills, Heat Distribution Plates

Page 20

BURNER ASSEMBLY/MAINTENANCE CONTINUED

5.Use a narrow bottle brush or a stiff wire bent into a small hook to run through each burner tube and flame port several times.

Note: Wear eye protection when performing procedure 6.

6.Use compressed air to blow into burner tube and out the flame ports. Check each port to make sure air comes out each hole.

7.Wire brush entire outer surface of burner to remove food residue and dirt.

8.Check burner for damage, if any large cracks or holes are found replace burner.

IMPORTANT: Burner opening must slide over valve nozzle.

9.Orient burners CORRECTLY by aligning screw hole in burner to the left as shown.

Note: Make sure burner tubes align evenly between crossover channels.

10. Replace screw on each burner and follow the "Gas Leak Testing" section of this manual. Relight burners to verify proper operation.

11.Replace heat distribution plates and cooking grills.

Valve Nozzle

Crossover Channel

Burner Opening

PROPER BURNER OPERATION

COOKING GRILLS

•Clean with mild soap detergent and water. A brass bristled brush or a nylon cleaning pad can be used to remove residue from the stainless steel surfaces. Do not use steel wire bristles to clean the cooking grills. Steel can cause the finish to chip or crack. DO NOT use a commercial oven cleaner.

HEAT DISTRIBUTION PLATES

•Periodically, it may be necessary to inspect and clean the heat distribution plate to prevent excess grease build-up. When the grill is cold, remove the cooking grills. Inspect the heat distribution plates and replace if broken or damaged. Do not allow heat distribution plates to become damaged to the extent that they may fall through onto the burners. Replace the heat distribution plates and cooking grills and light the burners. Operate the grill on "HIGH" for 10 minutes to remove the excess grease.

19

Page 19 Page 21
Image 20
Page 19 Page 21
Contents Triple Function Important Safety Table of Contents GAS Grill General Warnings Installation Information LP GAS Cylinder not Supplied with this GrillCylinder Specifications Installing the LP GAS Cylinder Onto the Grill Regulator Resetting ProcedureFilling the LP GAS Cylinder Hose and RegulatorConnecting Hose and Regulator to AN LP GAS Cylinder Connecting Hose and RegulatorChecking for Leaks Leak TestingWhen to Perform a Leak Test PRE-START Check List Match Lighting the Main Burners Lighting InstructionsLighting the Main Burners Turning OFF the Grill Operating the GrillBreaking in Your Grill Preheating the GrillCleanliness Grilling to Proper TemperatureTo Minimize FLARE-UPS Indirect CookingCharcoal Grill General Warnings Page Charcoal Operating Instructions Preheating Your GrillSmoking GRILLING/SEARINGFlavoring Wood To Increase HeatAdding CHARCOAL/WOOD During Cooking Transporting and StorageBurner ASSEMBLY/MAINTENANCE Proper Care & MaintenanceCleaning and Maintenance Cooking Grills Heat Distribution PlatesTrouble Shooting Before Storing Your GrillFrequently Asked Questions Frequently Asked Questions Assembly Instructions Page Parts BAG Contents Step M6 X 15mm bolts Step Place the control knobs on the control panel M4 X 10mm bolts, and M4 nuts Step Place the ash pan inside the firebox Step Step Brinkmann 3830 Assembled Importantes Advertencias DE Seguridad Sección DE LA Parrilla DE GAS Sección DEL Carbón DE LeñaAdvertencias Generales Para LA Parrilla DE GAS Información DE Instalación Especificaciones DEL Cilindro Procedimiento DE Reposición DEL Regulador Llenado DEL Cilindro DE GAS DE Propano LíquidoManguera Y Regulador Conexión DE LA Manguera Y Regulador Verificación DE Ausencia DE Fugas Pruebas DE Detección DE FugasCuándo Realizar UNA Prueba DE Detección DE Fugas Lista DE Verificación Preliminar AL Encendido ¡PRECAUCIÓNEncendido DE LAS Hornillas Principales CON UN Cerillo Instrucciones DE EncendidoEncendido DE LAS Hornillas Principales Apagado DE LA Parrilla Operación DE LA ParrillaPreparación DE LA Parrilla Para Usarla POR Primera VEZ Precalentamiento DE LA ParrillaPara Reducir AL Mínimo LAS Llamaradas Cocción IndirectaLimpieza Cocinar a LA Parrilla a LA Temperatura ApropiadaAdvertencia Advertencia Instrucciones DE Operación DE LA Parrilla DE Carbón DE Leña Cómo Precalentar SU ParrillaAhumar Cómo Asar Y ChamuscarLeña QUE Imparte Sabor Cómo Incrementar LA TemperaturaCómo Añadir Carbón O Leña Durante EL Cocimiento Transporte Y AlmacenamientoCómo Ensamblar Y Darle Mantenimiento a LOS Quemadores Debido Cuidado Y MantenimientoLimpieza Y Mantenimiento Parrillas Para Cocinar Placas DE Distribución TérmicaResolución DE Problemas Antes DE Almacenar SU ParrillaLAS Preguntas MÁS Frecuentes LAS Preguntas MÁS Frecuentes Instrucciones DE Ensamblado Page Arandelas De Resorte M10 Paso Paso M6 X 15mm, arandelas M6 y tuercas M6 Coloque las perillas de control en el panel de control Advertencia Perilla del Respiradero Coloque la cacerola de ceniza dentro de la caja de fuego Paso Paso Brinkmann 3830 Armada ONE Year Limited Warranty

CHARCOAL SMOKER CHARCOAL GRILL specifications

The Brinkmann Charcoal Smoker Charcoal Grill serves as a versatile cooking solution for both outdoor grilling and smoking enthusiasts. Combining the traditional methods of charcoal cooking with modern design, this grill promises a rich flavor and tender results that only charcoal can deliver.

One of the standout features of the Brinkmann Charcoal Smoker Grill is its dual functionality. It employs a unique horizontal smoker design that allows users to smoke meat on one side while grilling on the other. This is perfect for those who want to serve a variety of dishes at their gatherings without the need for multiple cooking devices.

The grill is equipped with a heavy-duty, durable steel construction that ensures long-lasting performance. This robust build is complemented by a corrosion-resistant finish, providing durability against the elements. For optimal heat retention and even cooking, the grill also features a firebox made from extra-thick materials.

Temperature regulation is a critical aspect of smoking and grilling. The Brinkmann grill features adjustable air vents that allow users to control the airflow, thus regulating the temperature inside the smoker. This provides the flexibility needed to achieve precise cooking temperatures, vital for low-and-slow smoking processes.

Another significant feature is its large cooking surface. The grill provides ample space for different types of food, from ribs and briskets to vegetables and seafood. This makes it suitable for family barbecues or larger gatherings. Additional features include chrome-plated cooking grates, which not only provide superior heat retention but are also easy to clean.

Moreover, the Brinkmann Charcoal Smoker Grill comes with a built-in temperature gauge, allowing users to monitor cooking conditions without opening the lid, helping to maintain a consistent cooking environment. The easy-access side door offers convenient access to the charcoal, making it effortless to replenish fuel without disturbing the cooking process.

Cleanup is simplified by the removable ash pan, which captures leftover ashes for easy disposal, allowing for hassle-free maintenance after your grilling session.

In summary, the Brinkmann Charcoal Smoker Charcoal Grill stands out for its rugged construction, versatile cooking options, efficient temperature control, and user-friendly features. Whether you are a seasoned pitmaster or a weekend enthusiast, this grill can elevate your outdoor cooking experience to new heights.
Top Page Image Contents