Brinkmann CHARCOAL SMOKER CHARCOAL GRILL Filling the LP GAS Cylinder, Hose and Regulator

Page 7

WARNING

FILLING THE LP GAS CYLINDER:

•Allow only qualified LP gas dealers to properly fill or repair your LP gas cylinder.

•New tanks should be purged prior to filling; inform LP gas dealer if you are using a new tank.

•DO NOT allow the cylinder to be filled beyond 80% capacity. Over-filled tanks can create a dangerous condition. Over-filled tanks can build-up pressure and cause the relief valve to expel propane gas vapors. The vapor is combustible and if it comes in contact with a spark source or flame an explosion causing severe burns, bodily harm, or death could occur.

•Always use a protective cylinder cap when grill is not connected to cylinder.

•If you exchange a cylinder with a qualified exchange program, be sure the cylinder has a Type 1 valve and an over-filling prevention device (OPD).

INSTALLING THE LP GAS CYLINDER ONTO THE GRILL:

1.Check that the cylinder valve is closed by turning the knob clockwise.

2.Place the cylinder into the tank holder in the bottom of cabinet.

3.Orient the cylinder such that the valve opening faces the right side table and so that the hose is not kinked or damaged.

4.Make sure tank sits securely in tank holder.

5.Attach or detach regulator to the LP gas cylinder only when cylinder is at rest in tank holder.

HOSE AND REGULATOR:

Your grill is equipped with a Type 1 connection device with the following features:

1.The system will not allow gas flow from the cylinder until a positive connection to the valve has been made.

Note: The cylinder valve must be turned off before any connection is made or removed.

2.A thermal device that will shut off the gas flow if the device is subject to temperatures above 240°F to 300°F (115°C to 150°C). If this should happen, remove the entire regulator assembly and dispose of properly. A replacement regulator assembly can be purchased by contacting customer service at 800-527-0717. The cause of the excessive heat should be determined and corrected before using your grill again.

3.A regulator flow limiting device, when activated, restricts the flow of gas to 10 cubic feet per hour. If the flow limiting device is activated, perform Regulator Resetting Procedure.

Tank Holder

Tank Holder

REGULATOR RESETTING PROCEDURE

1.Turn burner control knobs to "OFF”, turn off the cylinder valve and disconnect regulator from LP gas tank. Wait approximately two minutes.

2.Reattach regulator and slowly turn cylinder valve back on. The flow limiting device will now be reset.

6

Page 6 Page 8
Image 7
Page 6 Page 8
Contents Triple Function Important Safety Table of Contents GAS Grill General Warnings LP GAS Cylinder not Supplied with this Grill Installation InformationCylinder Specifications Hose and Regulator Installing the LP GAS Cylinder Onto the GrillRegulator Resetting Procedure Filling the LP GAS CylinderConnecting Hose and Regulator Connecting Hose and Regulator to AN LP GAS CylinderWhen to Perform a Leak Test Leak TestingChecking for Leaks PRE-START Check List Lighting the Main Burners Lighting InstructionsMatch Lighting the Main Burners Preheating the Grill Turning OFF the GrillOperating the Grill Breaking in Your GrillIndirect Cooking CleanlinessGrilling to Proper Temperature To Minimize FLARE-UPSCharcoal Grill General Warnings Page Preheating Your Grill Charcoal Operating InstructionsTo Increase Heat SmokingGRILLING/SEARING Flavoring WoodTransporting and Storage Adding CHARCOAL/WOOD During CookingCleaning and Maintenance Proper Care & MaintenanceBurner ASSEMBLY/MAINTENANCE Heat Distribution Plates Cooking GrillsBefore Storing Your Grill Trouble ShootingFrequently Asked Questions Frequently Asked Questions Assembly Instructions Page Parts BAG Contents Step M6 X 15mm bolts Step Place the control knobs on the control panel M4 X 10mm bolts, and M4 nuts Step Place the ash pan inside the firebox Step Step Brinkmann 3830 Assembled Importantes Advertencias DE Seguridad Sección DEL Carbón DE Leña Sección DE LA Parrilla DE GASAdvertencias Generales Para LA Parrilla DE GAS Información DE Instalación Especificaciones DEL Cilindro Manguera Y Regulador Llenado DEL Cilindro DE GAS DE Propano LíquidoProcedimiento DE Reposición DEL Regulador Conexión DE LA Manguera Y Regulador Cuándo Realizar UNA Prueba DE Detección DE Fugas Pruebas DE Detección DE FugasVerificación DE Ausencia DE Fugas ¡PRECAUCIÓN Lista DE Verificación Preliminar AL EncendidoEncendido DE LAS Hornillas Principales Instrucciones DE EncendidoEncendido DE LAS Hornillas Principales CON UN Cerillo Precalentamiento DE LA Parrilla Apagado DE LA ParrillaOperación DE LA Parrilla Preparación DE LA Parrilla Para Usarla POR Primera VEZCocinar a LA Parrilla a LA Temperatura Apropiada Para Reducir AL Mínimo LAS LlamaradasCocción Indirecta LimpiezaAdvertencia Advertencia Cómo Precalentar SU Parrilla Instrucciones DE Operación DE LA Parrilla DE Carbón DE LeñaCómo Incrementar LA Temperatura AhumarCómo Asar Y Chamuscar Leña QUE Imparte SaborTransporte Y Almacenamiento Cómo Añadir Carbón O Leña Durante EL CocimientoLimpieza Y Mantenimiento Debido Cuidado Y MantenimientoCómo Ensamblar Y Darle Mantenimiento a LOS Quemadores Placas DE Distribución Térmica Parrillas Para CocinarAntes DE Almacenar SU Parrilla Resolución DE ProblemasLAS Preguntas MÁS Frecuentes LAS Preguntas MÁS Frecuentes Instrucciones DE Ensamblado Page Arandelas De Resorte M10 Paso Paso M6 X 15mm, arandelas M6 y tuercas M6 Coloque las perillas de control en el panel de control Advertencia Perilla del Respiradero Coloque la cacerola de ceniza dentro de la caja de fuego Paso Paso Brinkmann 3830 Armada ONE Year Limited Warranty

CHARCOAL SMOKER CHARCOAL GRILL specifications

The Brinkmann Charcoal Smoker Charcoal Grill serves as a versatile cooking solution for both outdoor grilling and smoking enthusiasts. Combining the traditional methods of charcoal cooking with modern design, this grill promises a rich flavor and tender results that only charcoal can deliver.

One of the standout features of the Brinkmann Charcoal Smoker Grill is its dual functionality. It employs a unique horizontal smoker design that allows users to smoke meat on one side while grilling on the other. This is perfect for those who want to serve a variety of dishes at their gatherings without the need for multiple cooking devices.

The grill is equipped with a heavy-duty, durable steel construction that ensures long-lasting performance. This robust build is complemented by a corrosion-resistant finish, providing durability against the elements. For optimal heat retention and even cooking, the grill also features a firebox made from extra-thick materials.

Temperature regulation is a critical aspect of smoking and grilling. The Brinkmann grill features adjustable air vents that allow users to control the airflow, thus regulating the temperature inside the smoker. This provides the flexibility needed to achieve precise cooking temperatures, vital for low-and-slow smoking processes.

Another significant feature is its large cooking surface. The grill provides ample space for different types of food, from ribs and briskets to vegetables and seafood. This makes it suitable for family barbecues or larger gatherings. Additional features include chrome-plated cooking grates, which not only provide superior heat retention but are also easy to clean.

Moreover, the Brinkmann Charcoal Smoker Grill comes with a built-in temperature gauge, allowing users to monitor cooking conditions without opening the lid, helping to maintain a consistent cooking environment. The easy-access side door offers convenient access to the charcoal, making it effortless to replenish fuel without disturbing the cooking process.

Cleanup is simplified by the removable ash pan, which captures leftover ashes for easy disposal, allowing for hassle-free maintenance after your grilling session.

In summary, the Brinkmann Charcoal Smoker Charcoal Grill stands out for its rugged construction, versatile cooking options, efficient temperature control, and user-friendly features. Whether you are a seasoned pitmaster or a weekend enthusiast, this grill can elevate your outdoor cooking experience to new heights.
Top Page Image Contents