Pride Mobility manual Quantum 500 Electrical Components

Page 18

I I I . Y O U R P O W E R C H A I R

Main Circuit Breaker: The main circuit breaker is a safety feature built into your power chair. When the batteries and the motors are heavily strained (e.g., from excessive loads), the main circuit breaker trips to prevent damage to the motors and the electronics. If the circuit trips, allow your power chair to “rest” for approximately one minute. Next, push in the circuit breaker button, turn on the controller, and continue normal operation. If the main circuit breaker continues to trip repeat- edly, contact your Quantum Rehab Specialist.

	MOTOR CONNECTORS
	BATTERY
CONTROLLERCABLE	CONNECTOR
CONTROLLERCABLE
TO VSI
	MAIN CIRCUIT BREAKER

Figure 7. Quantum 500 Electrical Components

www.quantumrehab.com

Quantum 500

Image 18

Contents Page F E T Y G U I D E L I N E S N T E N T S N T R O D U C T I O N PURCHASER’S AgreementInformation Exchange Pride Owners Club My Quantum Rehab SpecialistProduct Safety Symbols S a F E T YS a F E T Y Pre-Ride Safety Check ModificationsWeight Limitations Tire InflationIncline Information Braking Information Cornering InformationPublic Streets and Roadways Stationary Obstacles Steps, Curbs, etc Freewheel ModeOutdoor Driving Surfaces Stairs and EscalatorsElevators TransfersDoors Lift/Elevation ProductsPositioning Belts Inclement Weather PrecautionsMotor Vehicle Transport Reaching and BendingAlcohol Electromagnetic and Radio Frequency Interference EMI/RFII . Y O U R P O W E R C H a I R QuantumQuantum 500 Specifications Quantum 500 Power Base Electrical ComponentsQuantum 500 Electrical Components Manual Freewheel Levers To engage or disengage the drive motorsInitial Assembly A S S E M B L YSeat Installation To install the seatController Installation Seat Height and Seat Angle Adjustment O M F O R T a D J U S T M E N T STo change the seat height To adjust the recline angle Seatback Angle AdjustmentTo adjust the seatback angle Seat PositionFoot Platform Depth To adjust the foot platform depth Armrest Width AdjustmentArmrest Angle Adjustment To change the armrest angle To change the armrest widthFoot Platform Angle To adjust the foot platform angleTo clamp the quick release fastener Controller PositionTo adjust the ELR length To adjust the SFR lengthTo adjust the ELR angle To adjust the forward/back positionTo change leg rest length a To adjust the leg rest lengthMulti-Axis Foot Plate To change foot plate position BB a T T E R I E S a N D C H a R G I N G Tochargethebatteriesusingtheoff-boardchargerBattery Break-in Batteries and ChargingHow often must I charge the batteries? Frequently Asked Questions FAQs Howdoesthechargerwork?Can I use a different battery charger? Daily UseHow should I store my power chair and its batteries? Why do my new batteries seem weak?How can I ensure maximum battery life? What about public transportation?VSI consists I . O P E R a T I O NVSI Electronic Controller JoystickOn/Off Key Battery Condition MeterKeypad Red, yellow, and green lights lit Batteries chargedBattery Connector Motor ConnectorsController Connector Power Seat Actuator ConnectorVSI Error Codes Thermal RollbackTemperature Care and MaintenanceShould your power chair come in contact with water I I . C a R E a N D M a I N T E N a N C ETo check the brakes Daily ChecksWeekly Checks Monthly ChecksCleaning Instructions Tire/Wheel Replacement Yearly ChecksStorage Battery Replacement To replace the batteriesBattery Installation When to See Your Quantum Rehab Specialist for Service Corrective MaintenanceW a R R a N T Y Service Checks and Warranty Service Reconditioned Units WarrantyWarranty Exclusions Exclusions also include components with damage caused byQuality Control Quantum Inspector