Kenmore 625.39356, 625.38356 owner manual Check List of STEP-BY-STEP Guides to Install

Page 21

CHECK LIST OF STEP-BY-STEP GUIDES TO

INSTALL

Review the following list to ensure you have completed all the installation procedures.

1.	Check the incoming			water. Has incoming water
	been	tested?
2.	Remove cardboard			packaging from salt tank.
3.	Is the	incoming water going			to the valve inlet?
4.	Is the	bypass	valve	placed	into the service
	position?
5.	Is the ground		clamp	installed?
6.	Are the drain lines clamped and secured?
7.	Is the	unit plugged		into a continuously live outlet?

Water Supply

Valve Inlet

Bypass Valve(s)

Single By-

@_e

Note: Stem may be installed in either direction. The end with writ-

ing should be pulled out for service

8.	Has	salt been added to the	salt tank?
9.	Has	the unit been sanitized?	See page 19.

FOR SERVICE

position.

Outlet

Valve

Bypass Valve

Inlet

Close bypass valve. Open inlet & outlet valves.

Valve

3-Valve

FIG. 30

Image 21

Contents Save this Manual Repair or Parts ? Call toll freeONE Year Limited Warranty on Water Softener TEN Year Limited Warranty Against LeaksDisclaimer of implied warranties limitation of remedies Questions? Page Inspectshipment Parts DescriptionsSmall Parts Plan Your Installation Proper Order to Install Water Treating EquipmentTools Needed PipeValve Where to Install the Water SoftenerDraw Your Pipes Fittings Suggested Slab Foundation InstallationDip Adding a pressure reducing valve may reduce the flow Before Installing Checks & TestsAssemble Inlet Outlet ADAPTORS, or Single Bypass Valve Bypass ValveInlet and Outlet Threaded Adaptors Valve Bypass Installing HoldingClips Bypass Valve Turned DownwardConnect the Softener Position Softener Into PlaceConnect the Valve Drain Hose Connect Salt Tank Overflow TubingIII Leak Test House Main Water Shutoff ValvesWater Meter Jumper Wire Installgroundingclampbetween Thesoftenerinand OUT PipesConnecting Transformer Cold Water Pipe GroundingProgram the Timer InstallcoversShows, refer to the Troubleshooting Section Restart the Water Heater SET Water Hardness Number SET Presenttime of DAY Hardness Number SET Regeneration TimeSanitize Your Water Softener AS Follows Sanitize the Water SoftenerAddingsalttothe Storagetank Water Softening Salt with IronRemoving Additives Has Salt been added to Salt tank? Unit been sanitized? See Check List of STEP-BY-STEP Guides to InstallRecharge NOW ExtrarechargeOptional Settings Salt Efficiency 12 / 24 Hour ClockCalifornia Efficiency Requirement Water Flow Through the Softener Error Code Recharge Time Remaining and Valve Position IndicatorsKenmores Ultra Cleansing Feature Program MemorySoft Water Service and Regeneration ServiceRegeneration Water Flow Through Softener in Backwash Water Flow Through Softener Brining and Brine RinseSoft Water Service and Regeneration Automatic Bypass Water Flow Through Softener Fast RinseElectronics Salt Bridge Salt BridgeKeeping the Water Softener Clean Nozzle & Venturi Cleaning Nozzle & VenturiIron from Resin BED Protect the Water Softener from Freezing Drain ALL Water from SoftenerProblemcause Checklist to Help YOU Save MoneyCorrection Model 38356 Timer Code S Model 39356 Timer Code S Bypass ValvesInches Flow Rate GPM Pressure Drop PSI vs. Flow Rate GPMEration Check Always Make These Initial Checks FirstProcedure for Removing Error Code From Faceplate Possible ProblemManual Initiated Electronics Diagnostics Code Most LikelyTimer PWA Replacement Troubleshooting Valve Position IndicatorsOther Information ModelBrine Valve Float Setting Checks, and the manual initiated diagnosticsManualadvanceregeneration Check Cycle Flow Rates Gallons PER MINDisassembly Rotary Valve ServiceAssembly To Relieve PressureWater Flow Through the Softener Valve Service CycleFill Cycle Brining and Brine Rinse CycleFast Rinse Cycle Valve Backwash CycleBackwash Cycle Fast Rinse CycleRating Decal Location Part Number Part Description Water Softener CompleteINLET-OUTLET Grounding Clamps Brine Valve Assembly 4212 Wear-Strip Seal Cross-Section View No. Number Part Description Your Home

Related manuals

Manual 48 pages 28.32 Kb

CHECK LIST OF STEP-BY-STEP GUIDES TO

INSTALL

Has

salt been added to the

salt tank?

the unit been sanitized?

See page 19.