| PROBLEM | CAUSE | CORRECTION |
Pressure reading | It is normal for "some" | If there is an excessive amount | |
on the regulated | pressure drop to occur. | of pressure drop when the | |
pressure gauge |
| accessory is used, adjust the | |
| regulator as instructed in the | ||
(if equipped) |
| ||
| Operation section. | ||
drops when an |
| ||
| NOTE: Adjust the regulated | ||
accessory is |
| ||
| pressure under flow conditions | ||
used. |
| ||
| (while accessory is being | ||
|
|
| |
|
|
| used). |
|
|
|
|
| Air leak from | Possible defect in safety | Operate safety valve manually |
| safety valve. | valve. | by pulling on ring. If valve still |
|
|
| leaks, it should be replaced. |
|
|
|
|
Compressor is | Prolonged excessive use | Decrease amount of air usage. | |
not supplying | of air. | Check the accessory air | |
enough air | Compressor is not large | ||
to operate | enough for air requirement. | requirement. If it is higher than | |
accessories. |
| the SCFM or pressure supplied | |
|
|
| by your air compressor, you |
|
|
| need a larger compressor. |
|
| Hole in hose. | Check and replace if required. |
|
| Check valve restricted. | Remove and clean, or replace. |
|
| Air leaks. | Tighten fittings. |
|
| Restricted air intake filter | Clean or replace air intake |
|
|
| filter. Do not operate the |
|
|
| air compressor with the |
|
|
| filter removed. Refer to the |
|
|
| "Air Filter" paragraph in the |
|
|
| "Maintenance " section. |
|
|
|
|
Restricted air | Dirty air filter. | Clean or replace. See Air Filter | |
intake. |
| paragraph in the Maintenance | |
|
|
| section. |
|
|
| |
Regulator knob | Damaged regulator. | Have checked by a Trained | |
has continuous |
| Service Technician. | |
air leak. |
|
| |
|
|
| |
Regulator will | Damaged regulator. | Have checked by a Trained | |
not shut off air |
| Service Technician. | |
outlet. |
|
| |
|
|
|
|
A07187 | 20- ENG |