Delta D25886 instruction manual Glossary, Duty Cycle, Specifications, Accessories, Model No 66-500

Page 8

GLOSSARY

Become familiar with these terms before operating the unit. CFM: Cubic feet per minute.

SCFM: Standard cubic feet per minute; a unit of measure of air delivery.

PSIG: Pounds per square inch gauge; a unit of measure of pressure.

Code Certification: Products that bear one or more of the following marks: UL, CUL, ETL, CETL, have been evaluated by OSHA certified independent safety laboratories and meet the applicable Underwriters Laboratories Standards for Safety.

Cut-In Pressure: While the motor is off, air tank pressure drops as you continue to use your accessory. When the tank pressure drops to a certain low level the motor will restart automatically. The low pressure at which the motor automatically restarts is called “cut-in” pressure.

Cut-Out Pressure: When an air compressor is turned on and begins to run, air pressure in the air tank begins to build. It builds to a certain high pressure before the motor automatically shuts off - protecting your air tank from pressure higher than its capacity. The high pressure at which the motor shuts off is called “cut-out” pressure.

Branch Circuit: Circuit carrying electricity from electrical panel to outlet.

DUTY CYCLE

Air compressors should be operated on not more than a 50% duty cycle. This means an air compressor that pumps air more than 50% of one hour is considered misuse, because the air compressor is undersized for the required air demand. Maximum compressor pumping time per hour is 30 minutes.

SPECIFICATIONS

Model No.	66-500
Horsepower Peak	2
Bore	1.875"
Stroke	1.250"
Voltage/Hertz/ Phase	120V/60Hz/1Ph
Minimum Branch Circuit Requirement	15 amps
*Fuse Type	Time Delay
Air Tank Capacity	8 gallons
Approximate Cut-in Pressure	100
Approximate Cut-out Pressure	125
SCFM @ 40 PSIG	3.7
SCFM @ 90 PSIG	2.6

A circuit breaker is preferred. Use only a fuse or circuit breaker that is the same rating as the branch circuit the air compressor is operated on. If compressor is connected to a circuit protected by fuses, use only time delay fuses. Time delay fuses should be marked "D" in Canada and "T" in the US.

ACCESSORIES

Accessories for this unit are available at the store the unit was purchased.

D25886

8- ENG

Image 8

Contents Oil-Free Air Compressor Safety Guidelines Definitions Serious injury Result in property damageHazard What Could HappenHOW to Prevent IT What can HappenHazard Belt can cause serious injury if they What can Happen HOW to Prevent ITNever operate the compressor with Fire, Inhalation, Damage to Vehicle Surfaces Specifications AccessoriesGlossary Duty CycleInstallation Assembly for Tank unitsLocation of the Air Compressor Compressor Saddle Screw HandleTab Wheel NutExtension Cords Volt U.S.A. PlugVoltage and Circuit Protection Operation Know Your Air Compressor Description of OperationPressure RegulatorBefore Each Start-Up How to StopBefore Starting Maintenance How to StartTo Check Safety Valve Customer ResponsibilitiesUnplug outfit Service and AdjustmentsTo Replace or Clean Check Valve Storage To Replace RegulatorTroubleshooting Pressure reading Problem Cause Correction AIR Compressor Diagram Parts List Part Number DescriptionAIR Compressor Pump Diagram Not Shown Kits AvailableLimited Warranty Compresor de Aire Sin Aceite Lesiones serias Resultar en lesiones menores oModeradas Instrucciones Importantes DE Seguridad Agregados Y Accesorios Códigos locales y federales, previo al Advertencia Riesgo DE Quemaduras ¿QUÉ Puede OCURRIR? Advertencia Riesgo DE Caida ¿QUÉ Puede OCURRIR?Advertencia Riesgo DE Operación Insegura ¿QUÉ Puede OCURRIR? Glosario Ciclo DE ServicioEspecificaciones AccesoriosInstalación Será necesario sujetar o soportar un lado delCables de extensión eléctrica Enchufe de 120 V, EE.UUEnchufe de 240 V, EE.UU Protección del voltaje y del circuito Operación Conozca su compresor de aireDescripción de operaciones Manómetro deCómo utilizar su unidad Cómo detenerlaAntes de poner en marcha Antes de cada puesta en marchaMantenimiento Cómo poner en marchaResponsabilidades del cliente Cómo verificar la válvula de seguridadServicio Y Ajustes Para reemplazar o limpiar la válvula reguladoraAfloje la tuerca de la salida del Tubo y muévala hacia el costadoAire, originando un riesgo de ruptura de sus paredes AlmacenajePara reemplazar el regulador Guía DE Duagnóstico DE Problemas Sobre la soldadura o cosaAire, ello lo debilitará. El Tanque podría romperse oDesciende cuando El motor no funciona Diagrama DEL Compresor DE AIR Lista DE Piezas Clave No No. De Pieza DescripciónDiagrama DE LA Bomba DEL Compresor No mostrado Kits disponiblesGarantía Limitada AÑO Garantía limitada sobre todos los serviciosCompresseur dair sans huile Des dommages à la propriété Ou la mortMoyennes Avertissement Risque D’EXPLOSION OU D’INCENDIE PréventionAvertissement Risque DE Projection D’OBJETS Avertissement Risque D’ÉCLATEMENTRisque Avertissement Risque DE Choc Électrique Avertissement Risque PAR InhalationAvertissement Risque DE Chute Avertissement Risque DE BrûluresAvertissement Risque Relié AUX Pièces Mobiles Avertissement Risque Dune Utilisation Dangereuse Cycle DE Service AccessoiresLexique SpécificationsÉcrou Emplacement du compresseur dairAssemblage pour appareils à réservoir Directives DE Mise À LA Terre RallongesProtection contre la surtension et protection du circuit Description du fonctionnement UtilisationFamiliarisez-vous avec votre compresseur dair Utilisation de lappareil Arrêt de lappareilAvant le démarrage Avant chaque mise en marcheEntretien Mise en marcheResponsabilités du client Vérification de la soupape de sûretéRemplacement ou nettoyage de la soupape de retenue Entertien ET RéglagesLeau dans le réservoir dair peut condenser. Si le Remplacement du régulateurRangement Peut éclater ou exploser DépannageSerrer Considérée normale Fusible sauté ou coupe-circuit Diagramme DU Compresseur À AIR Liste DES Piêces Clé No Nº de Pièce DescriptionDiagramme DU Pompe Kit disponibles Non montréAN Garantie limitée sur tous les accessoires Garantie Limitée