SECTION 4
WIRING SCHEMATICS
4.1 INTRODUCTION
This Section contains wiring schematics for the AirV units.
Figure 4--1 is the schematic for the standard upper unit assembly and it is applicable to all standard units. Figure 4--2 is the schematic for the Low Profile upper unit assembly.
Figure 4--3 is the schematic for a free blow ceiling unit without heat while Figure 4--4 is a free blow unit with heat. Figure 4--5 is for a ducted unit with microprocessor control.
Figure 4--6 is for an Upper Unit Heat Pump with free blow application and Figure 4--7 is the matching free blow ceiling unit.
Figure 4--8 is for the Upper Unit Heat Pump ducted application and Figure 4--9 is the matching ducted ceiling unit.
Note that the ducted units have 115 VAC power for the components and 12 VDC power for the microprocessor control system.
Figure 4--10 is for the ducted or free blow application that uses a wall--mounted thermostat, with or without the furnace option.
Where applicable, diagrams that designate 115 Volt, 60 H, 1 Phase, are also available using 220 Volts, 50 H, 1 Phase. Most noteably Figure 4--1 and Figure 4--5.
| 4P |
|
| 2P | FAN MOTOR |
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
|
| |||
| 1 | BLK |
| 1 | BLK |
|
|
|
| BRN |
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
| 2 | BLU | 2 | BLU |
|
|
|
| WHT |
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
| 3 |
|
|
|
|
|
|
|
| GRN/YEL |
|
|
|
|
|
PLUG CONNECTS |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
| GRN/YEL | GRN/YEL |
| WHT |
|
|
|
| F |
|
|
| |||
TO CEILING UNIT |
|
|
|
|
| C | CAPACITOR | ||||||||
4 |
|
|
|
| H | ||||||||||
SEE FIG> |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
OR |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 2P | CONTROL | EVAP. |
|
|
|
|
| RED RED |
| BLU |
|
| ||
| BOX |
|
| WHT |
|
|
|
|
|
|
| ||||
| 1 |
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
| R |
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
| 2 | YEL |
|
| 1 | 2 |
| YEL | C |
| PTC |
|
|
| |
|
|
|
|
|
| BLU |
|
|
| ||||||
|
|
|
| OVERLOAD PROTECTOR |
|
|
|
|
| ||||||
|
|
|
| S |
|
|
|
|
| ||||||
|
|
|
|
| (If Used) |
|
| COMPRESSOR |
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
| Figure |
|
|
|
| |||||||||
(UNIT - |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
PLUG CONNECTS TO CEILING UNIT. SEE DIAGRAM SUPPLIED WITH CEILING UNIT FOR ADDITIONAL WIRING. | 4P |
|
|
|
|
| 4P |
|
|
|
| INDOOR FAN MOTOR | |||
BLK |
|
|
|
|
|
|
|
|
|
|
|
| |||
1 |
|
|
| 1 | 1 |
|
| BLK |
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
| ||||
2 | BLU |
|
|
| 2 | 2 |
|
| BLU |
|
|
|
| GRN/YEL | |
|
|
|
|
|
|
|
|
|
|
| |||||
3 | WHT |
|
| WHT | 3 | 3 |
|
| WHT |
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
| ||||
4 | GRN/YEL |
|
| BRN | 4 | 4 |
|
| BRN |
|
|
|
|
| |
|
| FMC |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
| YEL |
| 3P |
| YEL |
|
| OUTDOOR FAN MOTOR | ||||
|
|
|
| 1 | 1 |
|
|
|
|
|
|
| |||
|
|
|
|
|
|
|
|
|
|
|
|
| |||
|
|
|
|
| 2 | 2 |
| WHT |
|
|
|
|
| ||
2P |
|
|
|
|
|
|
|
|
|
|
|
| |||
WHT |
|
|
| 3 | 3 |
|
| BRN |
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
| |||||
1 |
|
|
|
|
|
|
|
| F |
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
| CAPACITOR | |||
2 | YEL |
|
|
|
|
| BRN |
|
|
| C | H | |||
|
|
|
|
|
|
|
| WHT |
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
| WHT | RED |
| BLU | ||
|
|
|
|
|
|
|
|
|
|
|
| ||||
|
|
|
| OLP |
|
|
| R | RED |
|
|
|
| ||
| LEGEND |
|
| (IF USED) |
|
|
|
| PTC |
|
| ||||
|
| YEL | YEL |
|
|
|
|
|
| ||||||
|
| 1 |
| 2 | C |
|
|
|
|
| |||||
|
|
|
|
|
| (IF USED) | |||||||||
|
|
|
|
|
|
|
|
|
| ||||||
| OLP: OVERLOAD PROTECTION |
|
|
|
| (3) |
|
| S | BLU |
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
| |||
| PTC: START THERMISTER |
|
|
|
|
|
|
|
|
|
|
|
|
| |
| JTB: JOINT TERMINAL BLOCK |
|
|
|
|
|
| COMPRESSOR |
|
|
|
|
| ||
| FMC: INDOOR FAN MOTOR CAPACITOR |
|
|
|
|
|
|
|
|
|
|
| |||
Figure | Low Profile |
|