Aquacal T115, T65, T135 owner manual Pool and Spa Heat Pump Installation Guide

Page 1

Pool and Spa

Heat Pump

Owner’s Manual

and

Installation Guide

PN: LTP0009 01/12/04

Models:

T65

T115

T135

(Also Applies to All C115 Models)

ATTENTION INSTALLER:

THIS DOCUMENT IS PURCHASER’S PROPERTY AND IS TO REMAIN WITH THE HEAT PUMP OWNER

1/7/04

AQ Technical, 9/24/04

Image 1

Contents Pool and Spa Heat Pump Installation Guide Page Table of Contents Eam ThermoLink Heat Exchanger Important Features Your NEW Heat PumpWater Temperature Safety Safety InformationHeater not Repairable by Owner Water Chemistry SafetyQuick Start & Stop Dimensional Information TropiCal Models T65 and T115 Physical Characteristics PerformanceDimensional Information TropiCal Model T135 Refrigerant Circuit Performance Charts TropiCal Table of SpecificationsRefrigerant Circuit Performance Charts Possible Conditions Guide Troubleshooting Refrigerant Circuit ProblemsPlacement of Heater InstallationIndoor Installation Outdoor InstallationIrrigation, Rainwater Runoff, and Landscape Features Typical Installation ClearancesEquipment Pad Requirements Anchoring Heater to PadPlumbing Requirements Plumbing Schematics Water in & OUT Connections Electrical RequirementsGeneral Information Reference Equipment Data Plate Code RequirementsGetting Familiar with Controls START-UP & OperationInitial Start-Up and Basic Operation Overview of ControlsPool/Spa Blankets Heating TipsPool and Spa Combination Heating Calculating Initial Heating TimeSpa Heating Heating in Cooler Weather Defrost CycleMaintenance General Maintenance Planned Maintenance ProgramMaintaining Proper Water Flow Maintaining Proper Clearances Around Heater Seasonal USE & Shut DownDuring the Swim Season Freeze protection / Extended shut downsLocation of Winterizing Drain Winterizing ProcedureCommon Troubleshooting Issues TroubleshootingHeat Pump Not Running Heat Pump Running but Not HeatingHeater Fails to Operate Troubleshooting Flow ChartsAnalog or Digital Controls 12/22/03 Heater Running but Not HeatingStart Determining Water Leaks vs. CondensationIf the heater is turning on Off every 5 minutes Heater Short CyclingPart Description Part Number Replacement PartsContacting the Factory What We Need to Know When You Call Us2737 24th St. North St. Petersburg, FL