Avalon Stoves Indoor Fireplace manual Sweep Ash Into Ashpan

Page 29

Maintenance2 9

Weekly Maintenance (or every 5 bags of pellets) - Continued

Sweep Ash Into Ashpan

HINT:	The more often you clean out the flyash, the more efficient your heater will burn.
NOTE:	Remove the ashbox prior to conducting the service below.
	WARNING:
	The firebox becomes very hot during operation. Let the stove cool completely before conducting service.

aSwing the side ash trap door up.

Ash Trap

Door

bLift it up and away from the firebox. Repeat for the opposite side.

c Lift the firepot out of its holder.	d Slide the ash pan trap door forward to expose the ash
	dumps (the door can be removed and cleaned if necessary)
Firepot

Ash Pan

Trap Door

	e	Brush all flyash into the ash dumps, including	f	Replace the ash trap doors and firepot.
		the flyash inside the firepot holder.		Slide the ash pan trap door forward.

HINT:

To empty the ashpan, see the instructions on the previous page.

Travis Industries

4 0 5 0 5 2 5

1 0 0 - 0 1 1 4 4

Image 29

Contents

Astoria Bay Pellet Insert Travis Industries 5 0 5 2 0 0 1 1 4 2IntroductionIntroduction Important Information Table of Contents Safety Precautions Mobile Home 6Specifications Installation7 Hopper Extension Set-up 8InstallationRe-install the hopper walls following the directions below Installation90Installation Venting the Pellet Stove Installation1Outside Air used for combustion 2InstallationMobile Home Requirements Restrictor Adjustment Baffle InstallationSurround Panel & Circuit Board Installation 4InstallationHint Installation into a Masonry FireplaceInstallation into a Factory Built Metal Fireplace 6InstallationOperation1 Safety NoticeLocation of Controls Starting the Heater for the First TimeTwo Modes of Operation 8OperationLoading Pellets To Adjust the Heat Manual ModeTo Start To Shut Down0Operation Auto ModeTo Adjust Room Temperature or Start the Stove Operation2 Adjusting the Fan Speed2Operation Maintenance Required LightStart-Up Sequence Auger on LightManual Auger Button Power OutagesUsing a Pellet/Corn Mix with This Heater Daily Maintenance whenever using the heater 4MaintenanceInspect the Burn Make Sure Pellets are Not Piling Up Check Firepot for Clinkers Maintenance2 Cleaning the Firepot Opening The Door 6MaintenanceClean the Hopper Weekly Maintenance or every 5 bags of pelletsClean the Heat Exchange Tubes Cleaning the Optional Plated SurfacesCheck Baffles, Ashbox, Ashpan, Dispose Ash If Necessary 8MaintenanceClean the Glass Sweep Ash Into Ashpan Remove the ashbox prior to conducting the service belowYearly Maintenance or every ton 0MaintenanceClean the Vent make sure the heater and vent is cool Maintenance3Door Alignment 2MaintenanceDoor Seal Hinge Adjustment Adjusting the Door Hinge and LatchCheck for Air Leaks Around the Door, Glass, and Ashpan Replacement PartsCovection Fan Normal Operating SoundsSerial No Safety LabelYears 1 & 2 Coverage Parts & Labor Limited 7 Year WarrantyThermostat 8Optional EquipmentZC Kit 9 9 2 0 0 1 4 Optional Equipment0Index