Avalon Stoves Indoor Fireplace manual 4Installation, Surround Panel & Circuit Board Installation

Page 14

1 4Installation

Surround Panel & Circuit Board Installation

N O T E : Attach the vent prior to installing the surround panels (& circuit board).

a

e Attach the surround panels to the insert by sliding the slots

 

on each panel over the tabs on the side of the insert.

Slot

NOTE: When in place, the

panels maintain a 3/8” gap

around the fireplace.

Tab

Phillips

Screwdriver

Remove the circuit board from the rear

hopper support. Disconnect the wiring

harness from the circuit board (see step

“d” below for a detailed view).

 

b

 

Bend these block-

 

off plates as

 

shown (both

Back of

sides). When in

Side Panel

position, they

 

block the view

 

through the slots.

 

in the surround

 

panels.

c

Attach the circuit board

with the four screws

shipped with the insert.

Phillips

Screwdriver

Right Side

Surround

Panel

Run the power cord to the side along the front of the fireplace behind the side panel (do not route it under the insert).

f

Install the top panel so the joggle clips slide over

the tabs on top of the side panels and insert.

Tighten the set screws from the back side with a small standard screwdriver

Top Trim

Place the right side surround panel near d the insert and attach the wiring harness

to the circuit board.

Back Side of

Circuit Board

Pinch these tabs to remove the wiring harness.

If using a thermostat,

 

attach the thermostat

Double-Back Tape

wires at this time.

Wiring Harness (disconnected in step “a”)

"L" Bracket

Top Panel

Right Side Trim

Optional Trim Installation:

Insert one leg of each "L" bracket into the top and side trim piece. Align the trim to form a precise corner, then tighten the two set screws with a small standard screwdriver. Slide the trim over the panels. Attach the double- back tape between the trim and panels at the bottom corners. This keeps the trim tight against

Travis Industries

4 0 5 0 5 2 5

1 0 0 - 0 1 1 4 4

Page 13 Page 15
Image 14
Page 13 Page 15
Contents Astoria Bay Pellet Insert Travis Industries 5 0 5 2 0 0 1 1 4 2IntroductionIntroduction Important Information Table of Contents Safety Precautions Mobile Home 6Specifications Installation7 8Installation Hopper Extension Set-upInstallation9 Re-install the hopper walls following the directions below0Installation Installation1 Venting the Pellet StoveOutside Air used for combustion 2InstallationMobile Home Requirements Baffle Installation Restrictor Adjustment4Installation Surround Panel & Circuit Board InstallationInstallation into a Masonry Fireplace Hint6Installation Installation into a Factory Built Metal FireplaceLocation of Controls Safety NoticeOperation1 Starting the Heater for the First TimeTwo Modes of Operation 8OperationLoading Pellets To Start Manual ModeTo Adjust the Heat To Shut Down0Operation Auto ModeTo Adjust Room Temperature or Start the Stove Adjusting the Fan Speed Operation2Start-Up Sequence Maintenance Required Light2Operation Auger on LightManual Auger Button Power OutagesUsing a Pellet/Corn Mix with This Heater Inspect the Burn 4MaintenanceDaily Maintenance whenever using the heater Make Sure Pellets are Not Piling UpCheck Firepot for Clinkers Maintenance2Cleaning the Firepot 6Maintenance Opening The DoorClean the Heat Exchange Tubes Weekly Maintenance or every 5 bags of pelletsClean the Hopper Cleaning the Optional Plated SurfacesCheck Baffles, Ashbox, Ashpan, Dispose Ash If Necessary 8MaintenanceClean the Glass Remove the ashbox prior to conducting the service below Sweep Ash Into Ashpan0Maintenance Yearly Maintenance or every tonMaintenance3 Clean the Vent make sure the heater and vent is coolDoor Alignment 2MaintenanceDoor Seal Adjusting the Door Hinge and Latch Hinge AdjustmentReplacement Parts Check for Air Leaks Around the Door, Glass, and AshpanNormal Operating Sounds Covection FanSafety Label Serial NoLimited 7 Year Warranty Years 1 & 2 Coverage Parts & Labor8Optional Equipment ThermostatOptional Equipment ZC Kit 9 9 2 0 0 1 40Index

Indoor Fireplace specifications

The Avalon Stoves Indoor Fireplace is a remarkable addition to any home, offering the perfect blend of aesthetics, functionality, and efficiency. Designed with a focus on both beauty and performance, this fireplace redefines the indoor heating experience while enhancing the ambiance of any living space.

One of the standout features of the Avalon Stoves Indoor Fireplace is its clean and contemporary design. Available in various styles and finishes, it fits seamlessly into diverse interior décors, from modern to rustic. The large glass viewing panel provides an expansive view of the flames, allowing users to enjoy the mesmerizing fire while adding warmth to the room.

Energy efficiency is at the heart of Avalon’s design philosophy. The fireplace is equipped with advanced combustion technology that maximizes burn efficiency, ensuring that more heat is extracted from the fuel. This leads to reduced fuel consumption and lower heating costs, making it an environmentally friendly choice. Some models feature a secondary combustion system, which allows the fireplace to burn cleaner, producing fewer emissions and adhering to stringent environmental regulations.

Another significant characteristic of the Avalon Stoves Indoor Fireplace is its versatility in fuel options. Homeowners can choose from traditional wood-burning models or the more contemporary propane and natural gas variants. This flexibility allows users to select the most suitable fuel source for their needs and preferences. The easy-to-use ignition systems further enhance the convenience of starting and maintaining the fire.

Safety features are paramount in the design of Avalon fireplaces. With options for air wash systems that keep the glass clean and cooling features to prevent overheating, users can enjoy a cozy fire with peace of mind. The construction materials are selected for their durability and heat resistance, ensuring that the fireplace stands the test of time.

In summary, the Avalon Stoves Indoor Fireplace combines an elegant design with advanced technology and safety features. Its energy efficiency, versatility in fuel options, and stylish appearance make it a top choice for those looking to add warmth and charm to their home. Whether for heating or simply enjoying the beauty of fire, Avalon offers a fireplace solution that meets modern lifestyles while providing a timeless appeal.
Top Page Image Contents