England's Stove Works 49-SCHPM, 10-CPM Accessory Items, Accessories and Options, Thermostat

Page 26

ACCESSORY ITEMS

The following accessories can be added to your unit at anytime after purchase; however, let the unit cool down before adding any accessories.

Thermostat

An external thermostat (such as our Part # PU‐DTSTAT (wall) or Part # AC‐3003 (remote)) can be used on our Pellet/Corn/Multi‐fuel units as long as it is a low‐voltage that works with millivolt systems. After unplugging the unit, locate the “jumper” wire (J‐18) on the bottom of the control board. The two screws should then be loosened and the jumper wire removed from the board. Next, the two thermostat lead wires should be slipped into these openings and the screws tightened; the jumper wire should be saved for future operation without a thermostat.

THERMOSTAT OPERATION: This stove is equipped with a unique, new feature that allows two options for

thermostatic operation: The stove comes from the factory pre‐programmed in “On/Off mode,” which turns the stove on and off when the call for heat comes or leaves, like a furnace. The second, or “High/Low mode,” burns at whichever heat range you set the stove at until the call for heat leaves, at which point the stove goes to the Low heat range setting.

To set the stove in the “High/Low mode,” unplug the unit and plug it back in, then press and release both down arrows; H L appears in the heat range and blower speed windows. The unit is now in “High/Low mode.” (Note: Repeat this to change back to “On/Off mode;” a 0 0 will appear in the heat range and blower speed windows). Using a thermostat in On/Off mode may shorten the life of your stove’s igniter.

Please note: Certain units may not respond to this; if your unit does not respond in this manner please contact Technical Support at (800) 245‐6489.

AC-109, AC-109BN Lip Trim

There is one piece of J-Channel trim that snaps onto the ash apron. Remove the protective covering from the trim and force the piece onto the edge. Although it should stay in place, stove cement can be used to secure it if necessary.

ACCESSORIES AND OPTIONS

PART NUMBER

PART DESCRIPTION

PU-OAK

Outside Air Kit (Now included with unit!)

AC-33000

3” Corn Vent Kit (Through-the-Wall)

AC-33100

4” Corn Vent Kit (Through-the-Wall)

PU-DTSTAT

Wall Thermostat

AC-3003

Remote Thermostat

AC-109

Brass Lip Trim

AC-109BN

Brushed Nickel Lip Trim

AC-MBSP

High Temp. Spray Paint

Replacement Parts, Accessories and Options can be ordered from the factory at:

(Parts orders ONLY) -- (800) 516-3636, or on our web site: www.englanderstoves.com .

If you have any questions or problems contact the Technical Support Department:

Technical Support Department

service@englanderstoves.com

P.O. Box 206

Parts Orders ONLY: 800-516-3636

Monroe, VA 24574

Questions: 800-245-6489

(Fax: 434-929-4810)

26

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING

CLEANING THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE

TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH QUESTIONS.

Page 25 Page 27
Image 26
Page 25 Page 27
Contents Model Numbers 10-CPM 49-TRCPM 49-SHCPM Must be maintainedLetter from our Technical Support department England’s Stove Works Technical Support Department 800Important Information Important Notice Unit Preparation Important Information Read Before OperatingPage Page Do not Connect to ANY AIR Distribution Duct or System Shelled Corn Burning Solid FuelsWood Pellets Cherry PitsFlue System Through the WallOutside Air Outside Combustion Air Intake Mobile Home InstallationThrough the Ceiling Floor Protection Freestanding Pellet/Corn/Multi-fuel InstallationFloor and Wall Protection Wall ProtectionOperating Instructions START- UP ProceduresSetting the Stirrer Bodily Injury can occurFuel not Feeding Correctly To remove the Stirrer for cleaning Changing from Pellets to Cherry Pits Fuel Change ProcedureChanging from Pellets to Corn Codes Operational NotesBox Parts Orders only Monroe, VA Questions Fax SHUT-DOWN Procedure From the Power SourceTechnical Support Department Daily Operation ASH Removal and Disposal Maintenance Semi-Weekly Ash MaintenanceAnnual Maintenance Ash PanMaintenance Replacing the Stirrer Drive Shaft Replacing the Stirrer Drive MotorRemoving Motor and Sprocket Glass GasketsFinish Control Board Recommended Heat RangesCircuit Board Functions Component Operation Start Operation ENDThermostat Accessory ItemsAccessories and Options AC-109, AC-109BN Lip TrimReplacement Parts CPM-APSee Item numbers on Exploded Diagram for part location Adjusting your Hopper Lid Latch Improper installation may cause a back draft Problem CauseSolution Problem Cause Solution Page Warranty is not Transferable Page Warranty Registration for England’s Stove Works Unit Information

40-TRCPM, 10-CPM, 49-SCHPM specifications

England's Stove Works is renowned for its commitment to crafting high-quality wood stoves and pellet stoves, and three of their notable products are the 49-SCHPM, 10-CPM, and 40-TRCPM models. Each of these stoves embodies the brand's dedication to efficiency, durability, and performance, making them popular choices for both heating homes and providing a cozy ambiance.

The 49-SCHPM is a powerful pellet stove designed to heat large spaces. It features a spacious hopper that can hold up to 60 pounds of pellets, allowing for extended burn times of up to 80 hours on lower settings. The stove incorporates an easy-to-use digital control board and a built-in thermostat, providing users with precise temperature regulation. This model also boasts a sleek, contemporary design, making it suitable for modern homes while still delivering traditional warmth.

In contrast, the 10-CPM is a compact and efficient pellet stove, ideal for smaller homes or tight spaces. Despite its smaller footprint, it still offers impressive heating capabilities with up to 35,000 BTU output, making it a formidable option for anyone seeking an efficient heat source without sacrificing performance. The 10-CPM features a large viewing window, which enhances the aesthetic appeal and allows users to enjoy the mesmerizing flames. It is also equipped with an automatic ignition system, making it convenient and easy to start.

The 40-TRCPM model showcases England's Stove Works' dedication to versatility. This multi-fuel stove can efficiently burn both wood pellets and corn, allowing homeowners the flexibility to choose their fuel source based on availability and cost. With an output capacity of 40,000 BTU, it is built to dominate larger areas while maintaining a steady heat output. The unit features a sophisticated combustion system that maximizes fuel efficiency and minimizes emissions, aligning with environmentally sustainable practices.

All three models utilize advanced engineering and technology to ensure an optimal burning experience. They come equipped with efficient air circulation systems and adjustable airflow to promote complete combustion, which results in less smoke and creosote buildup. This not only enhances safety but also contributes to the longevity of each unit.

Overall, England's Stove Works has established a strong reputation for producing reliable, efficient, and aesthetically pleasing stoves. The 49-SCHPM, 10-CPM, and 40-TRCPM exemplify the brand's commitment to quality and innovation, making them solid choices for anyone looking to enhance their home's heating system.
Top Page Image Contents