Frymaster H14 Series service manual 2 MH/BIH214, 314, 414, 514 Cabinet Assemblies

Page 86

8.2.2 MH/BIH214, 314, 414, 514 Cabinet Assemblies
4	27	28	24	26			5
							32
		1
		23						Detail B
							25
		8
							10
		3	21	7	9	13	6	29
			21	7	9	13	6	29
							31
								17	16
			22		See
					See
					Detail B
					18
		30					20
		30							19
									19
			See Detail A				12	15
							12	15
		2		11	14
								Detail A

ITEM	PART #	COMPONENT
1	200-0076	Divider, Cabinet, Common Electric
2	200-0084	Brace, Rear Horizontal, 2 Battery (Quad and Double)
*	200-0085	Brace, Rear Horizontal, 3 Battery (Triple)
3	200-0091	Rail, Top- Quad Cabinet
*	200-0072	Rail, Top- Triple Cabinet
*	200-0081SP	Rail, Top- Double Cabinet
4	200-0092	Support, Rear, Common Electric
5	200-0126	Brace, Rear Support
6	200-0138	Door Post, Common Electric (Triple, Quad w/filter; Double,
		Triple, Quad N/F)
7	201-0093	Enclosure, Rear Upright with Hole (Quad Only)
8	201-0137	Upright, Rear Enclosure, Common Electric
9	202-0093	Enclosure, Rear Upright with Hole (Quad Only)
10	202-0137	Upright, Rear Enclosure, Common Electric
11	806-7005SP	Base, Filter Assembly, Common Electric- Quad
*	806-6513SP	Base, Filter Assembly, Common Electric- Triple
*	806-6511SP	Base, Filter Assembly, Common Electric- Double
*	806-6997SP	Base Assembly, Common Electric N/F- Double
*	806-6999SP	Base Assembly, Common Electric N/F- Triple
*	806-7001SP	Base Assembly, Common Electric N/F- Quad
12	826-1376	Nut, 10-32 (Qty: 10)

8-4

Image 86

Contents Frymaster H14 Series Electric Fryer Computers FCC Warranty Statement Parts Return General Safety InformationIntroduction Computer Information European Community CE Specific InformationShipping Damage Claim Procedure Service InformationInstallation Instructions Do not block the area around the base or under the fryersPower Requirements After Fryers Are Under The Fry Station HoodFrypot Boil-Out Introduction To The M-100B Cooking Computer Equipment Setup and Shutdown ProceduresOperating Fryers With M100B Cooking Computers ShutdownDescription M-100B Computer Operating Instructions Operating the Computer on Full-Vat FryersOperating the Computer on Split-Vat Fryers M-100B Computer Problem Condition Indicators Open Drain Valve IndicationRecovery Out of Range REC LOC M-100B Computer Set-Up and Programming Instructions 1 M-100B Computer Setup ModeHow to Enter the Setup Mode How to Change Computer Product/Temperature Displays How to Change the Computer’s Display LanguageHow to Configure the Computer for Use on an Electric Fryer How to Activate or Deactivate the Frypot BOIL-OUT Feature How to Reset the Computer to the Factory Defaults 2 M-100B Computer Programming ModeHow to Enter the Program Mode How to Change the Cooking Temperature Setpoint How to Enter a Product Name in a Test MenuPage How to Suppress a Shake, QA, or Duty Function How to Use the Filter Countdown Timer How to Display Use Time InformationHow to Display the Product Cycle Accumulator Information Operating Fryers With Analog Controllers Introduction to the Analog ControllerI J K L M N Analog Controller Operating Instructions Analog Controller High-Limit CheckPage Operating the BUILT-IN Filtration System Description FunctionSTEP-BY-STEP Filtration Instructions Page Page Page Page Page Page Page Care and Cleaning of Your Fryer and Filter System Water in the Filter PAN MSDU50 Preventive Maintenance and Troubleshooting Preventive Maintenance TroubleshootingComputer Panel Open Interface Board Visible Fryer Heating Oil Computer Panel Open Interface Board VisibleFrom Preceeding From Preceeding Is the AL LED illuminated? Controller Panel Open Interface Board Visible From Preceeding From Preceeding Pump Motor Actuation Filter System OperationService Procedures Replace ControllerReplace Interface Board Replace Temperature Probe Replace TransformerReplace Temperature Probe Replace Heating Element Replace Heating Element Remove the element mounting screws Left element- 9-pin Right element- 6-pin Connector Replace HIGH-LIMIT Replace Frypot Replace Contactor Contactor mounting screws BUILT-IN Filter System Service Procedures Filtration Problem ResolutionBUILT-IN Filter System Service Procedures FootPrint III Wiring Diagram Electric Interface Board Diagnostic Chart Diagnostic LED LegendSimplified Wiring DiagramsCommon Electric McDONALDS H14 SERIES- FULL-VAT Common Electric McDONALDS H14 SERIES- DUAL-VAT GNDCommon Electric McDONALDS H14 SERIES- FULL-VAT- Export WYE Common Electric McDONALDS H14 SERIES- DUAL-VAT- Export WYE Wiring DIAGRAMS, Main McDonald’s DomesticMcDonald’s European Community CE McDonald’s European Community CE Prior To 9/98 McDonald’s European Community CE XBIH14 McDonald’s Domestic Contactor McDonald’s European Community CE WYE Contactor McDonald’s European Community CE XBIH14 Contactor McDonald’s 440/480V Contactor McDonald’s Delta CSA Contactor McDonald’s Domestic Control Cord McDonald’s English Control Cord Footprint III, Late Configuration Wiring DIAGRAMS, Filter UnitsFootprint III, Early Configuration H14 Series Electric Fryers Parts List AccessoriesPage Side , Cabinet 2 MH/BIH214, 314, 414, 514 Cabinet Assemblies Component Casters, Legs and Associated Hardware Component Box Assemblies/Associated Component Parts Page Control Panel Assembly Door Assembly Components Controller Assemblies Drain System Components Page McDonald’s Domestic, Dual-vat Elements and Related Components Component Hood Relay Box, Power Cords and Hood Cords Filter Base/Pan Assemblies 8.9.1 Filter Base Assemblies Filter Base Assembly, FootPrint Filter Pan Assemblies Filter Pan Assembly, Single FootPrint Filter Pump and Motor Assemblies Pump and Motor Assembly, 250V 50/60 Hz Page Flex Line Assembly, With Male/Female Ends Oil Return Linkage Assemblies and Components Frypot Assemblies and Drain Valve Components Thermostats and Related Components