Frymaster H14 Series service manual Care and Cleaning of Your Fryer and Filter System

Page 38

The oil may drop below operating temperature during the filtering process. In that case, the fryer will display Low-Temp and heat the oil when it is turned on.

Return fryer to operation, or filter another frypot in the battery. Remember, only one frypot can be filtered at a time.

8.2 CARE AND CLEANING OF YOUR FRYER AND FILTER SYSTEM

CAUTION: Never operate the fryer or filter system without vegetable oil in the system.

1.Filter vegetable oil as often as needed. If a heavy volume of breaded food is fried, filter as often as every hour. Filtering often increases the life of the vegetable oil and produces a better-tasting product. The best rule to follow is to "filter before you think it is needed". Even with a product such as french fries, you should filter two to three times per day for best results.

2.Periodically clean the frypot. Cleaning the frypot, combined with disposing of old vegetable oil enhances the flavor of the food product. After the fryer is empty, drain the frypot and close the drain valve. Fill the frypot to the OIL LEVEL line (or the bottom line for fryers equipped with two oil-level lines) with water and the correct amount of McD All Purpose Concentrate (APC) Cleaner HSC. Place the baskets into the frypot and bring the solution to a simmer at 195° F (90.5° C) for 1 hour. Turn OFF the fryer, drain the solution and wipe the frypot clean and dry.

NOTE: Do not drain water into the filter pan. Water will damage the filter pump enough to require replacement. Use a stockpot or bucket.

3.The filter pan and filter base assembly must be cleaned on initial start-up and periodically thereafter.

a.To clean the filter pan, lift pan from the filter base. Take the filter pan to a sink filled with warm water and grease-cutting detergent.

b.Scrub the filter pan with the frypot brush shipped with the fryer.

c.Rinse the filter pan thoroughly to remove the detergent. Wipe dry with a clean, dry cloth or paper towels.

5-10

Image 38

Contents Frymaster H14 Series Electric Fryer Computers FCC Warranty Statement Parts Return General Safety InformationIntroduction Computer Information European Community CE Specific InformationShipping Damage Claim Procedure Service InformationInstallation Instructions Do not block the area around the base or under the fryersPower Requirements After Fryers Are Under The Fry Station HoodFrypot Boil-Out Introduction To The M-100B Cooking Computer Equipment Setup and Shutdown ProceduresOperating Fryers With M100B Cooking Computers ShutdownDescription M-100B Computer Operating Instructions Operating the Computer on Full-Vat FryersOperating the Computer on Split-Vat Fryers M-100B Computer Problem Condition Indicators Open Drain Valve IndicationRecovery Out of Range REC LOC M-100B Computer Set-Up and Programming Instructions 1 M-100B Computer Setup ModeHow to Enter the Setup Mode How to Change Computer Product/Temperature Displays How to Change the Computer’s Display LanguageHow to Configure the Computer for Use on an Electric Fryer How to Activate or Deactivate the Frypot BOIL-OUT Feature How to Reset the Computer to the Factory Defaults 2 M-100B Computer Programming ModeHow to Enter the Program Mode How to Change the Cooking Temperature Setpoint How to Enter a Product Name in a Test MenuPage How to Suppress a Shake, QA, or Duty Function How to Use the Filter Countdown Timer How to Display Use Time InformationHow to Display the Product Cycle Accumulator Information Operating Fryers With Analog Controllers Introduction to the Analog ControllerI J K L M N Analog Controller Operating Instructions Analog Controller High-Limit CheckPage Operating the BUILT-IN Filtration System Description FunctionSTEP-BY-STEP Filtration Instructions Page Page Page Page Page Page Page Care and Cleaning of Your Fryer and Filter System Water in the Filter PAN MSDU50 Preventive Maintenance and Troubleshooting Preventive Maintenance TroubleshootingComputer Panel Open Interface Board Visible Fryer Heating Oil Computer Panel Open Interface Board VisibleFrom Preceeding From Preceeding Is the AL LED illuminated? Controller Panel Open Interface Board Visible From Preceeding From Preceeding Pump Motor Actuation Filter System OperationService Procedures Replace ControllerReplace Interface Board Replace Temperature Probe Replace TransformerReplace Temperature Probe Replace Heating Element Replace Heating Element Remove the element mounting screws Left element- 9-pin Right element- 6-pin Connector Replace HIGH-LIMIT Replace Frypot Replace Contactor Contactor mounting screws BUILT-IN Filter System Service Procedures Filtration Problem ResolutionBUILT-IN Filter System Service Procedures FootPrint III Wiring Diagram Electric Interface Board Diagnostic Chart Diagnostic LED LegendSimplified Wiring DiagramsCommon Electric McDONALDS H14 SERIES- FULL-VAT Common Electric McDONALDS H14 SERIES- DUAL-VAT GNDCommon Electric McDONALDS H14 SERIES- FULL-VAT- Export WYE Common Electric McDONALDS H14 SERIES- DUAL-VAT- Export WYE Wiring DIAGRAMS, Main McDonald’s DomesticMcDonald’s European Community CE McDonald’s European Community CE Prior To 9/98 McDonald’s European Community CE XBIH14 McDonald’s Domestic Contactor McDonald’s European Community CE WYE Contactor McDonald’s European Community CE XBIH14 Contactor McDonald’s 440/480V Contactor McDonald’s Delta CSA Contactor McDonald’s Domestic Control Cord McDonald’s English Control Cord Footprint III, Late Configuration Wiring DIAGRAMS, Filter UnitsFootprint III, Early Configuration H14 Series Electric Fryers Parts List AccessoriesPage Side , Cabinet 2 MH/BIH214, 314, 414, 514 Cabinet Assemblies Component Casters, Legs and Associated Hardware Component Box Assemblies/Associated Component Parts Page Control Panel Assembly Door Assembly Components Controller Assemblies Drain System Components Page McDonald’s Domestic, Dual-vat Elements and Related Components Component Hood Relay Box, Power Cords and Hood Cords Filter Base/Pan Assemblies 8.9.1 Filter Base Assemblies Filter Base Assembly, FootPrint Filter Pan Assemblies Filter Pan Assembly, Single FootPrint Filter Pump and Motor Assemblies Pump and Motor Assembly, 250V 50/60 Hz Page Flex Line Assembly, With Male/Female Ends Oil Return Linkage Assemblies and Components Frypot Assemblies and Drain Valve Components Thermostats and Related Components