Frymaster H14 Series service manual Control Panel Assembly

Page 91

ITEM

PART #

COMPONENT

1

 

Control Panel Assembly

 

806-9821SP

Center Brace, Control Panel (Double, Triple, Quad)

 

809-0396 Screw, #6-32 x 3/8 Phillips Pan Head, Type F

 

900-2732 Bracket, Control Panel Support

 

910-4808 Frame, Control Panel Bottom, Single

 

910-7045 Frame, Control Panel Bottom, Double

 

910-9256 Frame, Control Panel Bottom, Triple

 

910-9419

Frame, Control Panel Bottom, Quad

 

911-2730

End, Control Panel (Left)

 

912-2730

End, Control Panel (Right)

2823-2307 Control Panel, with Slot

3824-0577 Top Cap, Single Fryer

*824-0575 Top Cap, Two-Fryer Battery

*824-0576 Top Cap, Three-Fryer Battery

*824-0578 Top Cap, Four-Fryer Battery

4823-1618 Basket Hanger, McDonald’s

5810-1401 Basket Hanger, Wire

6810-1403 Basket Hanger, Wire-Offset

7824-0532 Housing, MAC114 Tilt w/o cap/splash

*824-0534 Housing, MAC214 Tilt w/o cap/splash

*824-0535 Housing, MAC314 Tilt w/o cap/splash

*824-0536 Housing, MAC414 Tilt w/o cap/splash

*910-7443 Top Connecting Strip (for fryers w/o cap/splash)

*910-2420 Strip, MAC114 Electric Hood (for fryers w/o cap/splash)

*910-2439 Strip, MAC 414 Electric Hood (for fryers w/o cap/splash)

*910-2440 Strip, MAC 314 Electric Hood (for fryers w/o cap/splash)

*910-2441 Strip, MAC 214 Electric Hood (for fryers w/o cap/splash)

8

824-0645 Housing, MAC114 HE Tilt with cap/splash

*824-0647 Housing, MAC214 HE Tilt with cap/splash

*824-0648 Housing, MAC314 HE Tilt with cap/splash

*824-0646 Housing, MAC414 HE Tilt with cap/splash *Not Illustrated

8-9

Page 90 Page 92
Image 91
Page 90 Page 92
Contents Frymaster H14 Series Electric Fryer Computers FCC Warranty Statement Parts Return Introduction Safety InformationGeneral European Community CE Specific Information Computer InformationService Information Shipping Damage Claim ProcedureDo not block the area around the base or under the fryers Installation InstructionsAfter Fryers Are Under The Fry Station Hood Power RequirementsFrypot Boil-Out Shutdown Equipment Setup and Shutdown ProceduresOperating Fryers With M100B Cooking Computers Introduction To The M-100B Cooking ComputerDescription Operating the Computer on Full-Vat Fryers M-100B Computer Operating InstructionsOperating the Computer on Split-Vat Fryers Open Drain Valve Indication M-100B Computer Problem Condition IndicatorsRecovery Out of Range REC LOC How to Enter the Setup Mode 1 M-100B Computer Setup ModeM-100B Computer Set-Up and Programming Instructions How to Configure the Computer for Use on an Electric Fryer How to Change the Computer’s Display LanguageHow to Change Computer Product/Temperature Displays How to Activate or Deactivate the Frypot BOIL-OUT Feature How to Enter the Program Mode 2 M-100B Computer Programming ModeHow to Reset the Computer to the Factory Defaults How to Enter a Product Name in a Test Menu How to Change the Cooking Temperature SetpointPage How to Suppress a Shake, QA, or Duty Function How to Display the Product Cycle Accumulator Information How to Display Use Time InformationHow to Use the Filter Countdown Timer Introduction to the Analog Controller Operating Fryers With Analog ControllersI J K L M N Analog Controller High-Limit Check Analog Controller Operating InstructionsPage Description Function Operating the BUILT-IN Filtration SystemSTEP-BY-STEP Filtration Instructions Page Page Page Page Page Page Page Care and Cleaning of Your Fryer and Filter System Water in the Filter PAN MSDU50 Preventive Maintenance Troubleshooting Preventive Maintenance and TroubleshootingComputer Panel Open Interface Board Visible Computer Panel Open Interface Board Visible Fryer Heating OilFrom Preceeding From Preceeding Is the AL LED illuminated? Controller Panel Open Interface Board Visible From Preceeding From Preceeding Filter System Operation Pump Motor ActuationReplace Controller Service ProceduresReplace Interface Board Replace Transformer Replace Temperature ProbeReplace Temperature Probe Replace Heating Element Replace Heating Element Remove the element mounting screws Left element- 9-pin Right element- 6-pin Connector Replace HIGH-LIMIT Replace Frypot Replace Contactor Contactor mounting screws Filtration Problem Resolution BUILT-IN Filter System Service ProceduresBUILT-IN Filter System Service Procedures FootPrint III Wiring Diagram Diagnostic LED Legend Electric Interface Board Diagnostic ChartCommon Electric McDONALDS H14 SERIES- FULL-VAT Wiring DiagramsSimplified GND Common Electric McDONALDS H14 SERIES- DUAL-VATCommon Electric McDONALDS H14 SERIES- FULL-VAT- Export WYE Common Electric McDONALDS H14 SERIES- DUAL-VAT- Export WYE McDonald’s Domestic Wiring DIAGRAMS, MainMcDonald’s European Community CE McDonald’s European Community CE Prior To 9/98 McDonald’s European Community CE XBIH14 McDonald’s Domestic Contactor McDonald’s European Community CE WYE Contactor McDonald’s European Community CE XBIH14 Contactor McDonald’s 440/480V Contactor McDonald’s Delta CSA Contactor McDonald’s Domestic Control Cord McDonald’s English Control Cord Footprint III, Early Configuration Wiring DIAGRAMS, Filter UnitsFootprint III, Late Configuration Accessories H14 Series Electric Fryers Parts ListPage Side , Cabinet 2 MH/BIH214, 314, 414, 514 Cabinet Assemblies Component Casters, Legs and Associated Hardware Component Box Assemblies/Associated Component Parts Page Control Panel Assembly Door Assembly Components Controller Assemblies Drain System Components Page McDonald’s Domestic, Dual-vat Elements and Related Components Component Hood Relay Box, Power Cords and Hood Cords Filter Base/Pan Assemblies 8.9.1 Filter Base Assemblies Filter Base Assembly, FootPrint Filter Pan Assemblies Filter Pan Assembly, Single FootPrint Filter Pump and Motor Assemblies Pump and Motor Assembly, 250V 50/60 Hz Page Flex Line Assembly, With Male/Female Ends Oil Return Linkage Assemblies and Components Frypot Assemblies and Drain Valve Components Thermostats and Related Components
Top Page Image Contents