Jackson Tempstar TGP technical manual Cantilever ARM Assembly

Page 27

CANTILEVER ARM ASSEMBLY

01

12

11

02

03

10

09


04			05		06		07		08


	ITEM	QTY	DESCRIPTION	MFG NO.

	01	1	Magnet, Reed Switch	5930-111-51-68
	02	1	Door Guide, Right Rear	5700-021-84-70
	03	1	Door, Right Side Assembly	5700-002-21-33
	04	2	Plug, Cantilever	5340-011-35-00
	05	2	Cantilever Arm Connector	5700-011-90-99
	06	1	Cantilever Arm	5700-031-50-67
	07	4	Washer, s/s 1/4" ID	5311-174-01-00
	07	4	Locknut, 1/4"- 20 s/s Hex w/Nylon Insert	5310-374-01-00
	08	6	Wear Button, 1/2" Dia, UHMW	5700-001-98-69
	09	2	Spring Rod	5700-001-28-18
	10	2	Cantilever Arm Support Bracket	5700-031-88-00
	11	2	Yoke Assembly	5700-000-75-78
	12	1	Hood Assembly	5700-041-90-56

25

Image 27

Contents Technical Manual Table of Contents Specifications of the Tempstar TGP Page GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure Auto Calibration AUTO-CALIBRATION ProcedureElectronics Control Board ECB Testing and Setting the Set Point TemperatureTo test the temperature at the T-in Thermistor Testing the ThermistorsGreen LED is off Control Board LED Light IndicationsSymptom Possible Cause Action Troubleshooting SectionMeasure the continuity between terminals # Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature DSI Polarity will Damage the Circuit BoardsPiston. If less than 2.0 VDC, replace Control board Remove burner manifold and check correct Letter DIM DimensionsOpening Letter DIM in DIM CM Table DimensionsShown Not Shown Main AssemblyQTY Description MFG no Control BOX Assembly Front ViewControl BOX Assembly TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Are not Included with This Assembly Not Shown Rinse Tank AssemblyRED Green LED Electronic Control Drawer ComponentsMetric Conversions Electrical Diagram