Jackson Tempstar TGP technical manual Control BOX Assembly TOP View

Page 25

CONTROL BOX ASSEMBLY - TOP VIEW

01

02

15

03

04	14
04
	13
05	12
05
06	11
	11

07

10

08

09


	ITEM	QTY	DESCRIPTION	MFG NO.

	01	2	Heyco Plug	5975-200-40-00
	02	1	Fitting, Co;nduit Non-Metalic, 3/4" x 45	5975-011-47-74
	03	1	Ground Lug	5940-200-76-00
	04	1	Terminal Block 2 pole	5940-500-09-61
	05	1	Contactor, 2 Pole, 220v, 20amp (Wash Motor)	5945-109-03-69
	06	1	Contactor, 2 Pole, 220v, 20amp (Wash Temperature)	5945-109-03-69
	07	1	Timer, 220v/ 50hz/ 8 Cam	5945-001-99-08
	08	1	Fuse Holder	5920-401-03-14
	09	1	Relay, Control 240v/ 50-60hz Top Mount	5945-111-47-51
	10	1	Liquid Level Control, (220v)	6680-200-08-21
	11	1	Inner Control Panel Assembly, TGP 208/50/1	5700-002-21-06
	12	4	Transformer Mounting Bracket	5700-002-18-95
	13	1	Transformer, 100-240vac to 24vdc	5950-002-19-88
	14	1	Transformer, 100-240vac to 12vdc	5950-002-17-87
	15	1	Fitting, Conduit Non-Metalic, 1/2" x 90	5975-011-45-14

23

Image 25

Contents Technical Manual Table of Contents Specifications of the Tempstar TGP Page GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure Auto Calibration AUTO-CALIBRATION ProcedureElectronics Control Board ECB Testing and Setting the Set Point TemperatureTo test the temperature at the T-in Thermistor Testing the ThermistorsGreen LED is off Control Board LED Light IndicationsSymptom Possible Cause Action Troubleshooting SectionMeasure the continuity between terminals # Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature DSI Polarity will Damage the Circuit BoardsPiston. If less than 2.0 VDC, replace Control board Remove burner manifold and check correct Letter DIM DimensionsOpening Letter DIM in DIM CM Table DimensionsShown Not Shown Main AssemblyQTY Description MFG no Control BOX Assembly Front ViewControl BOX Assembly TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Are not Included with This Assembly Not Shown Rinse Tank AssemblyRED Green LED Electronic Control Drawer ComponentsMetric Conversions Electrical Diagram