Jackson Tempstar TGP technical manual GAS Pack Assembly

Page 33

GAS PACK ASSEMBLY

01

02

03

04

05

06

07

08


	ITEM	QTY	DESCRIPTION	MFG NO.

		1	Gas Pack (TOWNGAS)	5700-002-19-83
	01	1	Hose, Flex Gas s/s Assembly	5700-011-93-95
	02a	1	Cover, Electronics Drawer w/Sight Glass	5700-002-18-62
	02b	1	Electronics Control Drawer Assembly	5700-002-21-10
	03	1	T-Mid Thermister Assembly	5700-002-12-22
	04	1	Valve, Solenoid,Combination Cut Off	4810-002-20-11
	05	1	T-In Thermister Assembly	5700-002-12-23
	06	1	Valve, Modulating 24v	4810-002-20-12
	07	1	Spark Probe Igniter	6680-002-12-24
	08	1	Heat Exchanger (copper)	5700-002-20-50

31

Image 33

Contents Technical Manual Table of Contents Specifications of the Tempstar TGP Page GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure Auto Calibration AUTO-CALIBRATION ProcedureElectronics Control Board ECB Testing and Setting the Set Point TemperatureTo test the temperature at the T-in Thermistor Testing the ThermistorsGreen LED is off Control Board LED Light IndicationsSymptom Possible Cause Action Troubleshooting SectionMeasure the continuity between terminals # Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature DSI Polarity will Damage the Circuit BoardsPiston. If less than 2.0 VDC, replace Control board Remove burner manifold and check correct Letter DIM DimensionsOpening Letter DIM in DIM CM Table DimensionsShown Not Shown Main AssemblyQTY Description MFG no Control BOX Assembly Front ViewControl BOX Assembly TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Are not Included with This Assembly Not Shown Rinse Tank AssemblyRED Green LED Electronic Control Drawer ComponentsMetric Conversions Electrical Diagram