Jackson Tempstar TGP technical manual Electronic Control Drawer Components, RED Green LED

Page 39

ELECTRONIC CONTROL DRAWER COMPONENTS

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

RED

 

GREEN

 

1

 

2

 

3

 

4

 

5

 

6

 

 

7

 

8

 

9

LED

 

LED

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

ITEM

QTY

DESCRIPTION

MFG NO.

 

 

 

 

 

 

 

 

01

1

Electronic Control Drawer Assembly

5700-002-21-10

 

 

02

1

Wiring Harness-Thermistor Cable

5700-002-12-34

 

 

03

1

Electronic Control Board (ECB)

6680-002-12-26

 

 

04

1

Wiring Harness-DSI Cable

5700-002-12-36

 

 

05

1

Wiring Harness-Power Supply Cable

5700-002-12-35

 

 

06

1

Wiring Harness-Modulating Valve (TGP)

5700-002-37-03

 

 

07

1

Direct Spark Ignition Board (DSI)

6680-002-12-25

 

 

08

1

Ignition Cable

5700-002-12-37

 

 

09

1

Circuit Breaker 3 amp

5925-022-36-94

 

37

Page 38 Page 40
Image 39
Page 38 Page 40
Contents Technical Manual Table of Contents Specifications of the Tempstar TGP Page GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure Auto Calibration AUTO-CALIBRATION ProcedureElectronics Control Board ECB Testing and Setting the Set Point TemperatureTo test the temperature at the T-in Thermistor Testing the ThermistorsGreen LED is off Control Board LED Light IndicationsSymptom Possible Cause Action Troubleshooting SectionMeasure the continuity between terminals # Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature DSI Polarity will Damage the Circuit BoardsPiston. If less than 2.0 VDC, replace Control board Remove burner manifold and check correct Letter DIM DimensionsOpening Letter DIM in DIM CM Table DimensionsShown Not Shown Main AssemblyQTY Description MFG no Control BOX Assembly Front ViewControl BOX Assembly TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Are not Included with This Assembly Not Shown Rinse Tank AssemblyRED Green LED Electronic Control Drawer ComponentsMetric Conversions Electrical Diagram
Top Page Image Contents