Russound CAM6.6X-S1/S2 Wiring Instructions, Keypad Wiring, CAT-5 Wire Color Type, Speaker Wiring

Page 27

INSTALLER

WIRING INSTRUCTIONS

CAUTION

Do not connect the controller's main power feed until all other connections have been made and verified. Live connection or removal of the keypad wiring or other wiring when the system is powered can cause communication problems in the network. Double-check terminations during each phase of the installation to prevent accidental damage. Incorrect wiring is the number one cause for non-warranty product damage.

Keypad Wiring

For the UNO-S2 and UNO-S1 keypad, the follow- ing connections are used to terminate the CAT-5 wire to the 110 punchdown on the keypad:

CAT-5 WIRE COLOR

TYPE

Brown . . . . . . . . . . . . . . . . . . . +12V

Brown/White . . . . . . . . . . . . . . +12V

Green . . . . . . . . . . . . . . . . . . Ground

Green/White . . . . . . . . . . . . Status In

Orange . . . . . . . . . . . . . . . . . Ground

Orange/White . . . . . . . . . . . . . IR Out

Blue . . . . . . . . . . . . . . . . . . . COM A

Blue/White . . . . . . . . . . . . . . COM B

To determine the amount of CAT-5 wire required for the system installation, first decide how many keypads will be used, then determine the distance between each intend- ed keypad location to the intended CAM6.6 location. The maximum recommended wire run length is 250 feet for each UNO Keypad.

RJ-45 Connections

The CAT-5 T568A wiring standard shown on the right is used for the RJ-45 terminations.

Make sure that the entire wire path between keypads and CAM6.6 is clear and not obstructed by a floor ceiling joist, or masonry wall which can’t be drilled through.

Confirm ahead of time that you can drill an outlet hole easily and in an unobtrusive spot to connect wires with the CAM6.6.

Label wires with keypad and room location. This simplifies CAM6.6 hook-up once the key- pads and speakers are installed.

Speaker Wiring

Standard 16-gauge 4-conductor stranded speaker wire can be run up to to 125 feet; 14-gauge wire can be run up to 250 feet.

When running wire, avoid locations conceal- ing pipes, heating ducts and AC wiring in the general vicinity.

Avoid running wires close to house electri- cal wiring for any distance. If you have to run them parallel, make sure to space the wires at least two feet from the AC line.

27

Image 27
Contents CAM6.6X-S1/S2 System Important Safeguards Table of Contents Reference Section Making ConnectionsOperation Component GuidesProduct Introduction Main Power and Zone Status Component GuideCAM6.6 Controller-Front Panel UNO-S1 Keypad-Front Panel BluesUNO-S2 Keypad-Front Panel CD PlayerFavorite 2 preset selections UNO-LRC1 Remote ControlUNO-S1 Keypad OperationUNO-S1 User Menu Operation User Menu SettingsFeature and Setting Party Party Mode Master or OffF1 and F2 Buttons UNO-S2 KeypadBalance Feature and Setting 1. BassUNO-S2 User Menu Operation TrebleInternal Source XM Tuner XM Radio OverviewDisplay Condition XM Radio Modes Category Search Now Playing Display PreferencesUNO-S1 UNO-S2 UNO-LRC1 Next Bank Next PresetPrevious Preset Preset ModeCategory Channel Up Category Search ModeNext Category Previous CategoryChannel Name CH Name Now Playing ModeDisplay Preference Mode Channel Number CH NumberUNO-S1 Keypad Control UNO-S1 Keypad Control of Tuner Selecting the tunerSelecting the desired channel UNO-S2 Keypad Control UNO-S2 Keypad Control of TunerXM Classics Recall Last Channel Setting a Memory PresetUser System Programming Overview Installation MenuSetup Menu Flow Charts Sample ConfigurationsCAM6.6X-S1/S2 System Components Tools needed for installationGetting Started Unpacking the System ComponentsSpeaker Wiring Wiring InstructionsKeypad Wiring CAT-5 Wire Color TypeCAM6.6 Controller-Rear Panel Installer Data Rx TTL Level Data Tx TTL Level GND +12VDC UNO-S1 Keypad-Update PortCAT-5 Connection UNO-S1 Keypad-CAT-5 Connection+12VDC UNO-S2 Keypad-Update PortData Rx RS-232 Data Tx RS-232 GNDUNO-S2 Keypad-CAT-5 Connection Keypad Location UNO-S1 KEYPAD-INSTALLATIONUNO-S2 KEYPAD-INSTALLATION UNO Keypad Port Connection CAM6.6 with Optional Internal Source XM satellite radio Source Audio and IR Input ConnectionsSource Audio Connections Source IR ConnectionsCommon IR Connections Common IR ConnectionSpeaker Connections Zone Fixed/Variable Audio Outputs 12VDC Home Theater Trigger In/Out 12VDC Home Theater Trigger12VDC 100mA Trigger Out 12VDC Mute Trigger In/Out 12VDC Mute Trigger12VDC Mute Trigger Out Rnet Link In and Link Out RS-232 Interface XM Signal Strength Mode Optional Internal Source XM Tuner AntennasXM Antenna Initial Install Test Number of Sources # of Sources/SOURCE Setup Flow Charts PagesInstallation Menu Pages Controller Setup Ctrlr SetupNumeric IR Source Setup Pages Basic Setup Source Setup PagesPeripheral Setup Pages 53-55 for Optional Internal Source Source Volume Trim Source SetupSetup Forms Mute Installer UNO-S1 Keypad Five-Character Display Installation Menu OverviewMemory # Memory NameBank # Are you sure? Sure? Please Wait Cycle Power Bank NameAll controllers Version Command TypeBuild Time Build DateSelected Unassigned Unasg KEY Name Device CodeKEY Function Save CHANGES? Trim LevelHighest NUM Suffix CMD Numeric TextPrefix CMD Selected Learned IRSRC SEL CMD SrcSC SysOn ZonVT Each zone. -16 dB lowest to 0 dB max-3dB defaultSyson Enable ZON VOL TrimInstallation Menu Power on CMD OnCmd Learned SRC Learn IR LrnIRMacro ID Command NUMLEARN/DELETE SUCCESS?#CONTROLLERS Peripheral Setup Memory Name, Bank Name Menu Flow ChartsSetup Menu Flow Charts Installer Periph Setup Installer Installer Mute Installer Installer LED on rear CAM Panel Blinks fast Installer Installer Device Codes for Video Acc IR CodesDevice Codes for TVs Device Codes for CableDevice Codes for SAT/DSS Device Codes for VCRsDevice Codes for Laser Disc Players Device Codes for CD Players Device Codes for DVD PlayersDevice Codes for Tuner/Amp Device Codes for Amp and Misc. AudioKEY Function UNO-S1 TV Hdtv KEY Codes TV HdtvSAP SAP, CC KEY Function UNO-S1 Cable KEY Codes CableSAP KEY Function UNO-S1 Video ACC KEY Codes Video ACCLanguage, MTS KEY Function UNO-S1 SAT/DSS KEY Codes SAT/DSSAlt/Audio,Lang.,CC KEY Codes VCRKEY Function UNO-S1 VCR KEY Codes VCR KEY Function UNO-S1 Laser Disc KEY Codes Laser DiscSubtitle, CC KEY Function UNO-S1 DVD KEY Codes DVDFormat Wide,Zoom,Aspect KEY Function UNO-S1 Receiver KEY Codes ReceiverDVD, LD KEY Function UNO-S1 AMP/MISC Audio KEY Codes AMP/MISC AudioTAPE, MD KEY Function UNO-S1 KEY Codes CDInput Tape, MD KEY Function UNO-S1 Home Control KEY Codes Home ControlInput Source/Scene UNO-S1 UNO-S2 Source NamesTivo Multiple Controllers with ONE Tuner Sample ConfigurationsMultiple Controllers with TWO Tuners ST2-XM Tuner Back Panel Multiple Controllers with Three TunersST2-XM Tuner Back Panel Multiple Controllers with ST2 Dual TunerTechnical Specifications Warranty & Repair 113 114 115