Thermador PRG36, PRG48, PRG304, PRDS48 installation instructions Testandadjustment, Step

Page 23

INSULATION AND RETAINER REMOVAL

Before the backguard can be assembled onto Model PRDS304, PRDS36 and PRDS48 Ranges, the insulation retainer and the insulation must be removed to avoid interference. This insulation is not required on the PRDS304, PRDS36 and PRDS48 models.

The High Shelf Back Trim is shown. The procedure is the same for Island Trim or Low Back Trim

Step 1

Remove the four (4) screws holding in insulation retainer. See Fig. 22a.

Step 2

Slide insulation retainer and insulation out and discard. See Fig. 22b.

NOTE: DO NOT REMOVE INSULATION WHEN INSTALLING A BACKGUARD ON MODELS PRG304, PRG36 AND PRG48 ALL-GAS RANGE.

STEP7:BACKGUARDINSTALLATION

FIG. 22a

➝

Screws

FIG. 22b

Insulation

Retainer

CAUTION

Thermador recommends that burner adjustments be made by a qualified technician at the time of installation. Extreme care should be used when adjustments are made after installation. Improper or lack of adjustments may void your

warranty.

STEP8:TESTANDADJUSTMENT

Install any loose components, such as burner caps and grates, that may have been removed earlier. Be certain that burner caps seat properly into the alignment slots in the burner bases. Before testing operation of the appliance, verify that the unit and the gas supply have been carefully checked for leaks and that the unit has been connected to the electric power supply. Turn the manual gas shut-off valve to the open position. Check operation of the sealed gas burners and grill by pushing and turning each knob counterclockwise to “HI”. The burner igniters will click until the flame ignites. The two far left sealed burners feature XLO®, causing the flame to cycle on and off when the knob is set to the XLO range. This is normal operation.

Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting of the flame from the burner. If any of these conditions exist, check that the air shutter (grill, griddle and gas oven only) or burner ports are not blocked or clogged. Remove any blockages that exist.

If the flame is too yellow, indicating insufficient air, adjust the shutter counterclockwise to increase air inlet (grill, griddle and gas oven only).

The sealed top burner flames should be approximately 1" to 1-1/4" high. The griddle, grill, gas oven and infrared broiler burner flames should be as shown in Fig. 23).

NOTE: No air shutter or low flame adjustment is necessary or possible with the sealed top burners.

Page 21

Page 22 Page 24
Image 23
Page 22 Page 24
Contents Installationinstructionsmanual Professionalranges Table of Contents Introduction ImportantinstallationinformationFor Residential Use Only AvertissementsenfrancaisAvertissement Select Hood and Blower Models VentilationrequirementsCabinet Clearances CabinetpreparationCabinetpreparation Typ ELECTRICALSUPPLY,DUALFUELRANGES UNPACKING, Moving and Placingthe Range UNPACKING,MOVING and Placingthe Range WiresProperty Damage INSTALLINGANTI-TIPDEVICERange Tipping Hazard Electrical Shock HazardPRDS304 and PRDS36 Dual Fuel Ranges Figure PRG304 and PRG36 All-Gas Ranges Figures 9, 10, 12a 12b PRDS304 and PRDS36 Dual-Fuel Ranges Figures 11, 14 Prds Wall Mount Propane Gas Requirements GasrequirementsandhookupHook UP Natural Gas RequirementsELECTRICALREQUIREMENTS,CONNECTION&GROUNDING Chart C Electrical Supply Circuit RequirementsChart D Power Supply Wire Rating and Size Requirements Location of Junction Box On PRDS304 Range Conductor Securement Do not Ground to a GAS Supply Pipe See . This method is not recommendedELECTRICALREQUIREMENTS,CONNECTIONS&GROUNDING BackguardinstallationChart D Backguard KIT Model Numbers Step TestandadjustmentGriddle Grill To Clean and Protect Exterior SurfacesElectrical InstallerchecklistFinal Check List GAS SupplyPage
Related manuals
Manual 28 pages 62.99 Kb Manual 120 pages 14.46 Kb Manual 67 pages 43.12 Kb Manual 88 pages 28.71 Kb

PRDS48, PRG304, PRG36, PRG48 specifications

The Thermador PRG30 and PRG36 represent the pinnacle of luxury cooking with their high-performance gas range features and advanced technology. Designed for serious home chefs, these models exemplify efficiency, style, and culinary excellence.

One of the most notable features of the Thermador PRG series is the powerful Pro Grand dual-fuel cooking system. With a combination of gas burners and an electric convection oven, these ranges allow for precision cooking and even heat distribution. The PRG30 boasts a compact size with 30 inches of width, while the PRG36 expands the cooking surface with 36 inches, accommodating larger pots and pans.

Both models come equipped with high BTU burners, reaching up to 18,000 BTUs on the powerful Star Sapphire burners. These allow for rapid boiling and intense heat, ideal for searing meats or achieving high-temperature sautéing. Furthermore, the PRG series includes an innovative simmer setting that enables precise low-heat cooking, perfect for delicate sauces or melting chocolate.

Thermador has integrated their patented Star Burner design in both models. This unique feature provides a larger flame spread compared to traditional round burners. Consequently, it allows for better heat distribution, significantly enhancing cooktop efficiency. The cooktop is designed with six burners, giving chefs the flexibility to cook multiple dishes simultaneously without sacrificing performance.

The ovens in the PRG30 and PRG36 are equally impressive, featuring a spacious capacity of 4.4 cubic feet. The Convection Bake function circulates air for optimal baking results, ensuring even browning and consistent cooking. The models also include a number of innovative cooking modes, such as the Bake, Broil, and Roast settings, enhancing the overall cooking experience.

Additionally, self-cleaning options simplify maintenance, allowing for effortless cleaning after extensive use. The design of the PRG series is complemented by a sleek stainless-steel exterior that not only adds elegance to the kitchen but is also durable and easy to maintain.

In terms of safety, both models feature a safety system that prevents accidental ignition and precise temperature control, ensuring a safe cooking environment. With a focus on high performance, cutting-edge technology, and meticulous design, the Thermador PRG30 and PRG36 gas ranges offer an unparalleled cooking experience for culinary enthusiasts looking to elevate their kitchen capabilities.
Top Page Image Contents