Alto-Shaam ASF-60E, ASF-75E, Electric Fryer manual Standard and Optional Filters, Filter Replacement

Page 20

o p e r a t i o n

oil filtration instructions (for units with installed option)

FILTER REPLACEMENT

1.With the DRAIN in the “closed” position, pull the trolley from the fryer and disconnect the hose from the fryer.

Use optional trolley handle if available, or take care when pulling trolley from fryer as it has sharp edges. (Contact factory for optional trolley handle information.)

2.Pushing down on filter frame 4 clip, pull side of filter cartridge A closest to clip upwards. Slide opposite edge of filter cartridge out from beneath the filter frame lip.

3.Remove used filter 2 and filter ring 3. Discard filter 2. Retain filter ring 3.

4.Place new filter 2 and filter ring 3 next to screen on underside of filter cartridge A. Reverse step 2 above.

5.Reconnect hose to fryer and return trolley to the full position under the fryer.

FILTER CARTRIDGE

FILTER

FILTER RING

(Use with paper filter only)

CLIP

FRAME LIP

FILTER FRAME

STANDARD and OPTIONAL FILTERS

part no.	description
FI-27791	PAPER (standard with fryer) 7-count package
FI-27794	PAPER (standard with fryer) 100-count package
FI-27648	CHARCOAL/CARBON FILTER 30-count pkg.
FI-27014	REUSABLE MESH FILTER, single

Electric Fryer Operation & Care Manual • 18

Image 20

Contents

Phone 262.251.3800 800.558.8744 USA/CANADA 262.251.7067 800.329.8744 U.S.A. onlyWire Diagrams Keep this Manual in a Convenient Location for Reference L I V E R yP a C K I N g Precautions InstallationSAFETy Procedures ASF 75E Specifications Weight estASF 60E Specifications SHORTENING/OILImproper Installation ALTERATION, Adjustment Operating and MaintenanceMinimum Clearance Requirements Do not USE Forklift from Front or Rear of UnitFryer is positioned firmly on all four Improper InstallationMAy Result in Fire N t i l a t i o n S t r a i n t requirements mobile equipment Risk of Electric ShockCasters must be a maximum height of 4-inches 102mm Chassis, approximately 7-inches 178mm fromHard wired models For Cleaning Electrical Connections MustE c t r i c a l requirements 230VE c t r i c a l installation R n i n gOperation L/s h o r t e n i ng requirementsOIL/SHORTENING Requirements Affecting product quality. Always filter the oil on aASF-75E ASF-60EASF-75E, 120V with filtration Boil out procedure Fill the fryer to the maximum oil fill line with water E r a t i o n For units without a pump or filtration system Pour aPOwER Source bEFORE CLEANINg or SERVICINg Start up & general operationDisconnect Unit from Sanitize the fryer station beforeCleaning & maintenance Thoroughly Clean DailySevere DAMAgE or Electrical HAzARD Could ResultOil filtration instructions for units with installed option Filter Replacement Standard and Optional FiltersFilter Cleaning & Maintenance Reusable Mesh Filter OptionOil discard hose option HO-27686 is available Cleaning & MaintenanceOil discard hose Option Deluxe control operation N e l identificationOn/Off key Temp toggle clear keyE r a t i ng the control Resetting the Product Counts Check Product CountsL uxe control operation Pr o d u c t Key programmingProgram a Product Set Global Temperature Gramming Mode Sys t e m programmingGramming Mode PROgRAM SUggESTED FRyINg TimesKEyS Eggplant Service ExTENDED limiTED frypOT wArrANTyR v i c e N t r o l troubleshooting Problem Cause SolutionFryer will not POWER-UP R v i c e O ubl e s h o o t i ngs e r v i c eFryer will not Heat Pump will not Return OILASF 60E withserviceautomatic lifts 380415 ASF-60E Model assemblyLower panel with Drain Pipe ASF 60E with automaticASF- 60E servicelifts5013777 Drain assembly 5014288 Control Panel assembly ASF 60E serviceValve-drain assembly 5007518 Lift assembly Drain Panel and SwitchesElements ASSY-ASF60E Element Guard5008682 Electric AssyASF 75E, servicewithfiltration & lifts See details for these assemblies on following pages5009630 Lift Assembly ASF 75E, with filtrationASF- 75E service& lifts5009179 Door Assembly 5009628 Kettle 5008595Control Panel 5009636 Panel, lower assy w/ filtration VALVE-BALL 1/2 NPT Panel Mount5008588 Fat drawer assembly 5009735 Mount-motor and electrical ASF 75E, serviceNofiltration or lifts ASF 75E, No filtrationASF- 75E orservicelifts Mount-motor & electrical 5009217 Panel, lower assy ASF 60E service ASF 60E service ASF 60E service ASF 60E service ASF 75E service ASF 75E service ASF 75E service ASF 75E service Transportation Damage and Claims Voltage Purchased From

Related manuals

Manual 2 pages 51.77 Kb

Manual 2 pages 5.54 Kb