Blodgett BC-20G manual Deliming with Deliming Pump

Page 30

Maintenance

Deliming

WARNING!!

Deliming solutions are hazardous and can cause burns to the skin and eyes. Wear protective clothing and eyewear when decalcifying your appliance.

Deliming of the steam generator is the single most important preventative maintenance task. Lime will build up inside the steam generator, reducing efficiency and causing damage to the level control system.

WARNING!!

Problems caused by insufficient deliming are not covered by the warranty.

This oven comes equipped with a Delime lamp to indicate when the steam generator needs to be delimed. The Delime lamp will flash when the steam generator has been run for the preset inter- val. The flashing Delime lamp does not impede the operation of the oven, as you can use the oven normally when the lap is flashing. You may choose the best time to start the deliming process.

NOTE: To further prevent buildup of scale, this oven will automatically drain the steam generator after 5 hours of being in the off mode.

WARNING!!

If the oven is hot, it must be placed in the cool down mode for 1 minute with the door open prior to starting the deliming process. Once the process has been started, the oven cannot be used until the process is complete. The total process time is approximately 45 minutes.

DELIMING WITH DELIMING PUMP

NOTE: The Delime lamp must be flashing to start this process.

1.Be sure the container delivering the deliming agent to the appliance is full.

2.Be sure the door is open.

3.Turn the oven into Cool Down mode. Press and release the On Demand Steam button. The Delime lamp will flash faster, acknowledg- ing the action.

4.Turn the oven to the OFF mode.

5.The remainder of the procedure is automatic. The Delime lamp will stay illuminated while the process is active. When the process is com- pleted, the Delime lamp will turn off indicating the appliance can now be used normally.

26

Page 29 Page 31
Image 30
Page 29 Page 31
Contents BC-20G Page Avertissement Page Table of Contents/Table des Matières Combination Steam and Hot Air mode you can Blodgett Combi-Oven/SteamerDescription of the Combi-Oven/Steamer About the OVEN/STEAMEROVEN/STEAMER Operation Oven Features IntroductionPlumbing -- BC-20G Owner’s ResponsibilitiesElectrical -- BC-20G GAS Pressure -- BC-20GLocation General Export InstallationsLocation and Ventilation BC-20GAgency Approvals Water Connection Use of poor quality water will invali- date your warrantyPlumbing Connections Drain ConnectionCanadian installation Electrical ConnectionsExample Gas ConnectionsGAS Piping Pipe Nominal Size, Inches LengthGas Inlet Orifice Size at Sea Level Manifold Pressure Pressure Regulation and TestingGAS Pressure PressureDoor Adjustment Final Check and AdjustmentsBefore Switching the Appliance on Hinges can also be adjusted as followsFinal Check Lists Electrical Control CompartmentPlumbing Final Check Oven Operational Tests What to do in the event of a power failure Safety Information for Gas UnitsSafety Tips General safety tipsGas Controls Controls IdentificationStandard Controls Steam on Demand How to set the Steam On Demand mode OperationTemperature Display --- gives cook tem- perature Optional Cook & HoldManual Operation Programmed OperationSteam on Demand Programming the Product Keys Programming the Manual KEYOptional Meat Probe Maintenance Spray Bottle Operating ProcedureCleaning the Exterior Cleaning and Preventive MaintenanceCleaning the Interior Preventive MaintenanceDeliming Deliming with Deliming PumpDeliming Interval Setting DelimingTo set the deliming interval Communication Explanation of outputTo view data BC-20G Le four-étuveur Combi de Blodgett Deux modes de cuisson à la vapeur et à l’airSéparément D combiné, ou D en séquence Description de le four-étuveur Combi de Blodgett Propos DU FOUR-ÉTUVEURFonctionnement DU FOUR-ÉTUVEUR Combi Caractéristiques Caractéristiques Électriques -- BC-20G Responsabilités du propriétaireAvertissement Caractéristiques PLOMBERIE-- BC-20GPression d’entrée dans l’appareil Pression DU GAZ -- BC-20GEntrée de gaz Pression dans la rampe à gazMises en service américaines et canadiennes Placement et VentilationPlacement Ventilation Mise en service dans les autres paysInstallations aux États-Unis et au Canada Installations des appareils exportésNormes et Codes ’usage d’eau de mauvaise qualité annule la garantie Raccordement de la plomberie’EAU Froid ET Chaud Raccordement DU DrainRaccordement à l’électricité Exemple Raccordement au gazConduit DE GAZ Longueur Diamètre interne po Du tuyau 2 poInstallations américaines et canadiennes Installation dans les autres paysPression DE GAZ Réglage DE LA Porte Vérification finale et derniers réglagesAvant DE Mettre L’APPAREIL EN Marche Le loquet peuvent aussi être réglées comme suitCompartiment DES Commandes Électriques Vérifications FinalesVérification Finale DE LA Tuyauterie Liste de vérification finale Essais DE Fonctionnement DU FourQue faire si vous percevez une odeur de gaz Renseignements sur la sécurité des appareils au gazConseils DE Sécurité Que faire en cas de panne de courantCommandes du gaz Identification DES Commandes Interrupteur DE Commande DE GAZVoyant DE Chaleur EN Marche Commandes standardIdentification DES Commandes Voyant DE Vapeur SUR DemandeFonctionnement Vapeur sur demandeCuisson et Pause en Option Fonctionnement Manuelle Fonctionnement Programmé Vapeur SUR DemandeProgrammation DES Touches DE Produits Programmation DE LA Touche Cuisson Manuelle Commande DE LA Sonde Thermique Sonde thermique optionnelleConnecteur DE LA Sonde Thermique Entretien Procédure de fonctionnement du pulvérisateurNettoyage DE L’EXTÉRIEUR Nettoyage et entretien préventifNettoyage DE L’INTÉRIEUR Entretien PréventifDétartrage Détartrage Avec LE Pompe DE DétartrageRéglage DE L’INTERVALLE DE Détartrage Qualité de l’eau au CanadaPour régler l’intervalle de détartrage Communications Pour visualiser les données

BC-20G specifications

The Blodgett BC-20G is a high-performance gas convection oven designed for commercial kitchens, catering operations, and foodservice establishments. Recognized for its reliability and efficiency, the BC-20G stands out as a versatile tool that enhances cooking capabilities while ensuring consistent results.

One of its main features is the 20 cu. ft. capacity, which allows for large batches of food to be prepared simultaneously. This spacious interior accommodates up to five full-size sheet pans, making it ideal for bakeries and restaurants that require substantial baking or roasting space. The oven’s ability to handle various cooking tasks—from baking bread to roasting meats—makes it a key asset in busy kitchen environments.

The BC-20G utilizes a unique convection cooking system that circulates hot air evenly throughout the cavity. This technology ensures uniform cooking results, allowing food to be cooked quickly and efficiently. The built-in, adjustable, high-quality blower provides even air circulation, minimizing hot and cold spots within the oven, which ultimately leads to better browning and overall texture of the food.

The oven features an intuitive digital control panel, which allows users to set precise cooking times and temperatures with ease. It also includes a programmable timer that helps in maintaining consistency across different dishes and cooking styles. The adjustable humidity feature further enhances the cooking process by allowing operators to introduce steam when needed, which is particularly useful for baking delicate items like soufflés or crusty bread.

In terms of construction, the Blodgett BC-20G is built with a durable stainless steel exterior and interior, ensuring longevity and ease of cleaning. The heavy-duty door is designed with a double-pane glass window that provides visibility while maintaining optimal temperatures inside. The unit is also equipped with insulated sidewalls to improve energy efficiency.

Additional characteristics include a safety shut-off feature, automatic ignition, and a removable rack guide that simplifies the loading and unloading process. The oven operates on natural gas or propane, providing flexibility depending on the kitchen's infrastructure.

In conclusion, the Blodgett BC-20G is an exceptional investment for any commercial kitchen looking to enhance their cooking capability. With its thoughtful design, advanced cooking technology, and robust construction, this gas convection oven delivers on performance, reliability, and versatility, making it a favorite among professional chefs and culinary experts.
Top Page Image Contents