Kohler 12RESM1 manual Generator Set Component Locations, 17/18 kW Models

Page 10

Control detail, top view	8

12

9

11

10

1

2 3 4

5 6

7 See control detail

18

19

20 21

22

26

25

17

23

ADV-7341A-B

	16	15 14	13		24
1.	Muffler			14.	Oil drain hose
2.	Oil check			15.	Nameplate location (on base)
3.	Oil fill			16.	Oil drain valve
4.	Air cleaner			17.	Exhaust outlet
5.	Spark plug locations (both sides)			18.	Field-connection terminal block location
6.	Oil filter			19.	LP fuel orifice location (inside hose fitting)
7.	Oil cooler location			20.	Gas regulator assembly
8.	DC-RET Digital Control display			21.	DSAI leads
9.	Generator set master switch (RUN-OFF/RESET-AUTO)			22.	Fuel inlet
10.	Line circuit breaker			23.	Air intake
11.	Fuses			24.	Battery cables
12.	RS-232 connector (for application program updates)			25.	Battery charger
13.	Engine starting battery location (battery purchased separately)			26.	120 VAC receptacle for battery charger

Figure 2 Generator Set Component Locations, 17/18 kW Models

10	TP-6516 4/09

Image 10

Contents Controller DC-RET Digital Control ModelsTP-6516 4/09d Engine Identification Product Identification InformationGenerator Set Identification Numbers Controller IdentificationTable of Contents TP-6516 4/09 Battery Safety Precautions and InstructionsAccidental Starting Exhaust System Engine Backfire/Flash FireFuel System Hazardous Voltage/ Moving Parts Hazardous NoiseHeavy Equipment Hot Parts Introduction DetailGenerator Set Component Locations, 17/18 kW Models Service Assistance TP-6516 4/09 Lifting InstallationGeneral Generator Set InspectionSee Section Generator Set Clearances, 12 kW Models, ADV-7466, Sheet Installation TP-6516 4/09 Generator Set Clearances, 17/18 kW Models, ADV-7341-B, Sheet Exhaust Requirements Power SupplyAir Requirements Fuel Requirements Fuel SupplyFuel Pipe Size Fuel ConversionFuel Conversion 17 Dsai Connection Electrical Connections AC ConnectionsRemote Start Connection Battery ChargerGrounding EZ-273000-J Engine starting battery location Carburetor Heater optional 24 Carburetor Heater, 17/18 kWPrestart Installation Check Startup NotificationInstallation TP-6516 4/09 Wiring Diagrams Wiring Diagrams and SchematicsSchematic Diagram, 12 kW Models, ADV-7351 Point-to-Point Wiring Diagram, 12 kW Models, GM52471 Schematic Diagram, Single Phase, 17/18 kW Models, ADV-7353 TP-6516 4/09 Wiring Diagrams Wiring Diagrams TP-6516 4/09 Appendix a Abbreviations AnsiLCB TP-6516 4/09 TP-6516 4/09 Page 2007, 2008, 2009 by Kohler Co. All rights reserved