Manuals / Antunes, AJ / Kitchen Appliance / Electric Steamer

Antunes, AJ MS-355, MS-250/255 Miracle Steamer, Problem, Possible Cause, Corrective Action

Models: MS-250/255 MS-355

1 28

Download 28 pages 49.51 Kb

Page 18

Manual background

A.J. Antunes & Co.

MIRACLE STEAMER

	Problem	Possible Cause	Corrective Action

	Unit heats up, pump or sole-	Programming.	See pages 8-10.
	noid valve works with the
	noid valve works with the	If Ready light does not light but the	Contact maintenance or AJA Authorized
	momentary switch but will	If Ready light does not light but the	Contact maintenance or AJA Authorized
	momentary switch but will	unit steams regularly, the Ready light	Service Center.
	not steam during timer	unit steams regularly, the Ready light	Service Center.
	not steam during timer	is inoperable.
	cycles.	is inoperable.
	cycles.
		If the Ready light does light and the	Contact maintenance or AJA Authorized
		unit does not steam, the control board	Service Center.
		is inoperable.

		*(Direct Feed Units) Quick-disconnect	Make sure the quick-disconnect and O-ring
		not connected properly or inoperable.	are properly positioned and are not dam-
			aged. Replace damaged parts.

		Water volume adjustment is too low.	Adjust the water volume control. See
			Calibration section of the manual.

		Water filter clogged.	Remove and clean filter.
		Inoperable solenoid or solenoid dam-	Make sure unit is connected to a cold water
		age caused by connecting a hot	supply. Contact maintenance or AJA
		water supply line.	Authorized Service Center.

		Inoperable control board.	Contact maintenance or AJA Authorized
			Service Center.
	Steam coming out around	Wingnut is loose.	Tighten wingnut.
	top covers or sides.	Wingnut is loose.	Tighten wingnut.
	top covers or sides.
		Generator cover damage.	Adjust or replace generator cover.

P/N 1010699 Rev. B		17

Image 18

Antunes, AJ MS-355, MS-250/255 owner manual Miracle Steamer, Problem, Possible Cause, Corrective Action

Contents

MIRACLE STEAMER Models MS-150/155 MS-250/255 & MS-355MANUFACTURING NUMBERS OWNER INFORMATION TABLE OF CONTENTSMIRACLE STEAMER Electrical Cord & Plug ConfigurationsIMPORTANT SAFETY INFORMATION MIRACLE STEAMERElectrical ground is required on this appli- ance Do not clean this appliance with a water jetMIRACLE STEAMER Do not use an extension cord with this applianceHard water spots should be sponged using a vinegar solution SPECIFICATIONSFinger marks and smears should be rubbed off using soap and water MIRACLE STEAMERMS-150/155 & MS-250/255 MIRACLE STEAMERA.J. Antunes & Co MS-355ONLY INSTALLATIONONLY 208 VACELECTRICAL SHOCK HAZARD NOTE Make sure filter inside tank is installed properlyMIRACLE STEAMER Electrical ground is required on this applianceMIRACLE STEAMER OPERATIONFigure 4. Connecting Water Supply to MS-250/255 Model MS-250/255Operating Instructions H2O setting Steam Shot Time is used to adjust theMIRACLE STEAMER ProgrammingNOTE 20 seconds is recommended 1500MIRACLE STEAMER NOTE 20 seconds is recommendedMIRACLE STEAMER Hi-Limit Reset ButtonFigure 7. Hi-Limit Reset Button MS-150 shown Steaming TipsFinger marks and smears should be rubbed off using soap and water MAINTENANCEStains and spots should be sponged using a vinegar solution Hard water spots should be sponged using a vinegar solutionMIRACLE STEAMER NOTE Use only a Aluminium safe de-liming productFigure 8. Miracle Steamer Components NOTE The MS-355 does not use a water filter MIRACLE STEAMERWater Filters-Models MS-150/155 Direct water hook-up Units MS-250/255MIRACLE STEAMER TROUBLESHOOTINGProblem Possible CauseMIRACLE STEAMER GeneratorProgramming section Possible Cause ProblemMIRACLE STEAMER Corrective ActionMS-150/155/250/255 REPLACEMENT PARTSMIRACLE STEAMER A.J. Antunes & CoDescription MIRACLE STEAMERItem Part No Item Part NoINSET C Model MS A INSET A Model MSINSET B Model MS NOTE Refer to parts list on pageMIRACLE STEAMER INSET A Model MSNOTE Refer to parts list on page INSET B Model MSDescription MIRACLE STEAMERItem Part No Item Part NoA.J. Antunes & Co NOTE Refer to parts list on pageMIRACLE STEAMER INSET A Model MSA.J. Antunes & Co NOTE Refer to parts list on pageMIRACLE STEAMER WADD ATERPart REPLACEMENT PARTS continuedMIRACLE STEAMER DescriptionMIRACLE STEAMER WIRING DIAGRAMSNOTE ALL WIRES TO BE 14 GA. AWM-105 C UNLESS OTHERWISE SPECIFIED1025 W. National Avenue Addison, Illinois LIMITED WARRANTYA.J. ANTUNES & CO Telephone 630 543-8650 FAX