Manuals / Axion / Lawn and Garden / Lawn Mower

Axion ZT18533, CZT2142 manual Reproduction

Models: ZT2142 CZT2142 ZT18533

1 48

Page 45

NOTES

Reproduction
Not	for

Page 45

Image 45

Axion ZT18533, CZT2142 manual Reproduction

Contents

Reproduction AxionNot/ 150Z SeriesOPERATOR’S MANUAL Reproduction Reproduction25 TABLE OF CONTENTSSpecifications Service ItemsSAFETY RULES GENERAL OPERATIONTRANSPORTING AND STORAGE CHILDREN SLOPE OPERATIONEMISSIONS TOWED EQUIPMENT RIDE-ON UNITSSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION Reproduc tionONLY RIDE UP AND DOWN HILL NOT ACROSS HILLSERVICE AND MAINTENANCE Service & MaintenanceSafe Handling of Gasoline Reproduction SAFETY & OPERATION DECALSIDENTIFICATION NUMBERS SAMPLEPRODUCT REFERENCE DATA CONTROL FUNCTIONS OPERATIONGround Speed Levers Parking Brake LeverMower Cutting Height Switch GENERAL OPERATING SAFETYIgnition Switch Mower Blade SwitchWARNING - TRAILERS CHECKS BEFORE STARTINGFUEL RECOMMENDATIONS STOPPING THE RIDER & ENGINE EMERGENCY STOPPINGPUSHING THE RIDER BY HAND STARTING THE ENGINEDRIVING PRACTICE sharply in reverse as when going forward, and backingBASIC DRIVING Smooth TravelPractice Turning Around a Corner ADVANCED DRIVINGPractice Turning In Place Executing TurnsRemoving the Mower Deck MOWER DECK REMOVAL & INSTALLATION - 33” DECKSMOWER DECK REMOVAL & INSTALLATION - 42” DECKS Installing the Mower DeckRemoving the Mower Deck MOWER DECK REMOVAL & INSTALLATION - 52” DECKS Installing the Mower DeckRemoving the Mower Deck MAINTENANCE SCHEDULE MAINTENANCERIDER MAINTENANCE, All Models ENGINE MAINTENANCEACCESSING THE ENGINE COMPARTMENT Rider Maintenance ItemsCLEAN DEBRIS FROM RIDER AND CLEAN DEBRIS FROM ENGINENotService Interval 25 hours LUBRICATIONReproduction GreaseReproduction Figure 23. Lubricating Rider Figure 24. Lubricating RiderFigure 25. Lubricating Mower Lift For your personal safety, blade mounting CLEAN DECK CHECK / REPLACE MOWER BLADEShardware must each be installed as per Figure 26. Blade Removal - 33” DeckReproduction CHECK RIDER SAFETY CLEAN THE BATTERY AND CABLESOperational SAFETY Checks NOTE On models with 33” decks, the battery is mountedRepro duction CHECK / ADJUST PTO CLUTCHCHANGE ENGINE OIL & FILTER CHANGE ENGINE OILNOTE Change engine oil while the engine is warm. Run the engine for a few minutes, then shut the engineAir Filter Removal & Installation SERVICE AIR FILTER & PRE-CLEANER - 18.5 & 21 HP ENGINESNOTE Air filter configuration may differ from shown Interval Pre-Cleaner Every 25 hours or as requiredService Interval Every 25 hours or as required Pre-Cleaner Service CLEAN COMBUSTION CHAMBERAir Filter Service NOTE Replace a worn or damaged pre-cleanerGROUND SPEED CONTROL LEVER ADJUSTMENT SERVICE & ADJUSTMENTSSPEED BALANCING ADJUSTMENT CUTTING HEIGHT ADJUSTMENTBRAKE ADJUSTMENT ENGINE ADJUSTMENTS3-1/2 8.89cm Side to Side Leveling - 33” Decks MOWER DECK LEVELING ADJUSTMENTSMOWER DECK LEVELING ADJUSTMENTS Side to Side Leveling - 42” & 52” DecksFront To Back Leveling - 33” Deck Measure the distance from the ground to front tip ofblade, and from ground to rear tip of blade Figures Front To Back Leveling - 42” & 52” Decks MOWER BELT REPLACEMENT Mower Drive Belt Replacement - 33” DecksMower Drive Belt Replacement - 42” Decks MOWER DECK WASHOUT PORT Arbor Drive Belt Replacement52” decks only NOTE It is not necessary to remove the mower deckSTORAGE STORAGEBefore Storage After StorageTroubleshooting the Rider TROUBLESHOOTINGTroubleshooting the Mower ENGINE 18.5HP SPECIFICATIONSCHASSIS ENGINE 21HPReplacement Parts SERVICE ITEMSMaintenance Items Technical ManualsReproduction Reproduction thatch problems HOW AND WHEN TO WATER, FERTILIZE & AERATEHOW HIGH TO MOW THE GRASS Tall Grass Requires Incremental CuttingNote Always operate the engine at full throttle when mowing WHEN AND HOW OFTEN TO MOWPROPER MOWING SPEED ReproductionBriggs & Stratton Yard Power Products Group ReproductionP RO D U C T S, I N C . 535 Macon Street McDonough, GA