Manuals / Axion / Lawn and Garden / Lawn Mower

Axion ZT18533, CZT2142 manual Reproduction

Models: ZT2142 CZT2142 ZT18533

1 48

Page 2

Reproduction
Not	for

Page 2

Image 2

Axion ZT18533, CZT2142 manual Reproduction

Contents

OPERATOR’S MANUAL ReproductionAxionNot/ 150Z Series Reproduction Specifications TABLE OF CONTENTSReproduction25 Service ItemsTRANSPORTING AND STORAGE SAFETY RULESGENERAL OPERATION EMISSIONS SLOPE OPERATIONCHILDREN TOWED EQUIPMENT RIDE-ON UNITSONLY RIDE UP AND DOWN HILL Reproduc tionSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION NOT ACROSS HILLSafe Handling of Gasoline SERVICE AND MAINTENANCEService & Maintenance SAFETY & OPERATION DECALS ReproductionPRODUCT REFERENCE DATA IDENTIFICATION NUMBERSSAMPLE Ground Speed Levers OPERATIONCONTROL FUNCTIONS Parking Brake LeverIgnition Switch GENERAL OPERATING SAFETYMower Cutting Height Switch Mower Blade SwitchFUEL RECOMMENDATIONS WARNING - TRAILERSCHECKS BEFORE STARTING PUSHING THE RIDER BY HAND EMERGENCY STOPPINGSTOPPING THE RIDER & ENGINE STARTING THE ENGINEBASIC DRIVING sharply in reverse as when going forward, and backingDRIVING PRACTICE Smooth TravelPractice Turning In Place ADVANCED DRIVINGPractice Turning Around a Corner Executing TurnsMOWER DECK REMOVAL & INSTALLATION - 33” DECKS Removing the Mower DeckRemoving the Mower Deck MOWER DECK REMOVAL & INSTALLATION - 42” DECKSInstalling the Mower Deck Removing the Mower Deck MOWER DECK REMOVAL & INSTALLATION - 52” DECKSInstalling the Mower Deck RIDER MAINTENANCE, All Models MAINTENANCEMAINTENANCE SCHEDULE ENGINE MAINTENANCECLEAN DEBRIS FROM RIDER AND Rider Maintenance ItemsACCESSING THE ENGINE COMPARTMENT CLEAN DEBRIS FROM ENGINENotReproduction LUBRICATIONService Interval 25 hours GreaseFigure 25. Lubricating Mower Lift ReproductionFigure 23. Lubricating Rider Figure 24. Lubricating Rider hardware must each be installed as per CLEAN DECK CHECK / REPLACE MOWER BLADESFor your personal safety, blade mounting Figure 26. Blade Removal - 33” DeckReproduction Operational SAFETY Checks CLEAN THE BATTERY AND CABLESCHECK RIDER SAFETY NOTE On models with 33” decks, the battery is mountedCHECK / ADJUST PTO CLUTCH Repro ductionNOTE Change engine oil while the engine is warm. Run CHANGE ENGINE OILCHANGE ENGINE OIL & FILTER the engine for a few minutes, then shut the engineNOTE Air filter configuration may differ from shown SERVICE AIR FILTER & PRE-CLEANER - 18.5 & 21 HP ENGINESAir Filter Removal & Installation Interval Pre-Cleaner Every 25 hours or as requiredService Interval Every 25 hours or as required Air Filter Service CLEAN COMBUSTION CHAMBERPre-Cleaner Service NOTE Replace a worn or damaged pre-cleanerSPEED BALANCING ADJUSTMENT SERVICE & ADJUSTMENTSGROUND SPEED CONTROL LEVER ADJUSTMENT CUTTING HEIGHT ADJUSTMENT3-1/2 8.89cm BRAKE ADJUSTMENTENGINE ADJUSTMENTS MOWER DECK LEVELING ADJUSTMENTS Side to Side Leveling - 33” DecksSide to Side Leveling - 42” & 52” Decks MOWER DECK LEVELING ADJUSTMENTSblade, and from ground to rear tip of blade Figures Front To Back Leveling - 33” DeckMeasure the distance from the ground to front tip of Front To Back Leveling - 42” & 52” Decks Mower Drive Belt Replacement - 42” Decks MOWER BELT REPLACEMENTMower Drive Belt Replacement - 33” Decks 52” decks only Arbor Drive Belt ReplacementMOWER DECK WASHOUT PORT NOTE It is not necessary to remove the mower deckBefore Storage STORAGESTORAGE After StorageTROUBLESHOOTING Troubleshooting the RiderTroubleshooting the Mower CHASSIS SPECIFICATIONSENGINE 18.5HP ENGINE 21HPMaintenance Items SERVICE ITEMSReplacement Parts Technical ManualsReproduction Reproduction HOW HIGH TO MOW THE GRASS HOW AND WHEN TO WATER, FERTILIZE & AERATEthatch problems Tall Grass Requires Incremental CuttingPROPER MOWING SPEED WHEN AND HOW OFTEN TO MOWNote Always operate the engine at full throttle when mowing ReproductionP RO D U C T S, I N C . 535 Macon Street McDonough, GA Briggs & Stratton Yard Power Products GroupReproduction