Manuals
/
Cornelius
/
Kitchen Appliance
/
Ice Maker
Cornelius
322 manual This Page Left Blank Intentionally, 3/17/95
Models:
322
1
5
32
32
Download
32 pages
61.15 Kb
1
2
3
4
5
6
7
8
<
>
Specifications
AVERAGE OPERATING CHARACTERISTICS AC322
Install
Warranty
All wiring must conform to national and local electrical codes
Starving TXV - Product Symptoms
Reset Operation
Checkout Procedure For Harvest Bin Switches
Error LED
Understand Signal Words
Page 5
Image 5
THIS PAGE LEFT BLANK INTENTIONALLY
166240008
2
3/17/95
Page 4
Page 6
Page 5
Image 5
Page 4
Page 6
Contents
SERIES ICE CUBE MACHINE
Ó IMI CORNELIUS INC
Service/Installation Guide
INSTALLATION INSTRUCTIONS FOR MOUNTING ON DRINK DISPENSERS
TABLE OF CONTENTS
CHECKOUT PROCEDURE FOR HARVEST BIN SWITCHES
ADJUSTMENT PROCEDURE FOR HARVEST BIN SWITCHES
Page
TABLE OF CONTENTS cont’d
Recognize Safety Information
SAFETY INFORMATION
Understand Signal Words
Follow Safety Instructions
3/17/95
THIS PAGE LEFT BLANK INTENTIONALLY
UNPACKING
SPECIFICATIONS
322 SERIES
Electrical
UNIT SET-UP
LEVELING
UNIT LOCATION
MAKE PLUMBING CONNECTIONS
MAKE ELECTRICAL POWER SUPPLY CONNECTION
For water cooled units
All wiring must conform to national and local electrical codes
DRAIN
DRAIN CONNECTION INSTALLATION INSTRUCTIONS
WATER LEVEL RESERVOIR
TYPICAL INSTALLATION ALL ELECTRICAL & PLUMBING
ILL023
STARTING THE UNIT
Adjustment Procedure For Harvest Bin Switches
INSTALLATION INSTRUCTIONS FOR MOUNTING ON DRINK DISPENSERS
Checkout Procedure For Harvest Bin Switches
SANITIZING AND CLEANING PROCEDURE
CAUTION Condenser cooling fins are sharp. Use care when cleaning
CLEANING THE AIR COOLED CONDENSER COIL
WATER TREATMENT
WINTER STORAGE
SI Units
IP Units
IP Units
SI Units
AIR COOLED CONDENSER
WATER REGULATING VALVE WATER-COOLED CONDENSER
DUMP CYCLE
ICE PRODUCTION CHECK
ADJUSTING BRIDGE THICKNESS
TOTAL ICE CAPACITY
LED INDICATORS
Error LED
STATUS INDICATOR
Curtain Open
Pre-Chill Mode
Transformer
CIRCUIT BOARD DIAGNOSIS
Evaporator Switches
RESET OPERATION
Harvest Safety Termination
Evaporator Proximity Switch
SENSOR THERMISTOR DIAGNOSIS
VOLTAGE SELECTOR SWITCH
THERMOSTATIC EXPANSION VALVES
Sensors
WATER REGULATING VALVE
Starving TXV - Product Symptoms
Flooding TXV - Product Symptoms
MOISTURE CONTAMINATION
SERVICE STEM VALVES
COMPRESSOR CONTACTOR
COMPRESSOR & STARTING COMPONENT CHECK-OUT PROCEDURE
Relay
rating
Current
Capacitors
Compressor
Leak Detection
SYSTEM EVACUATION & RECHARGING
SELF-CONTAINED PRODUCTS
REFRIGERANT DEFINITIONS ASHRAE
NOTE There is no pressure control used to cycle the fan motor
HIGH PRESSURE SAFETY SWITCH
CONDENSER FAN CYCLING CONTROL
TO THE ORIGINAL OWNER OF A CORNELIUS COMMERCIAL CUBE ICEMAKER
CORNELIUS LIMITED COMMERCIAL WARRANTY PLAN
Puerto Rico only
IMI CORNELIUS INC
One Cornelius Place Anoka, Minnesota Telephone 800 Facsimile
IMI CORNELIUS INC
Corporate Headquarters
