Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius manual FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT, Operator’s Manual

Models: R-404A

1 28

Download 28 pages 1.64 Kb

Page 1

FCB POST-MIX DISPENSER

FCB POST-MIX DISPENSER

WITH V4 FEATURES

(R-404A REFRIGERANT)

Operator’s Manual

Part No 312030002

May 8, 1996

Control Code A

THIS DOCUMENT CONTAINS IMPORTANT INFORMATION

This Manual must be read and understood before installing or operating this equipment

IMI CORNELIUS INC; 1996

PRINTED IN U.S.A

Image 1

Cornelius manual FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT, Operator’s Manual,  Imi Cornelius Inc

Contents

Operator’s Manual FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT IMI CORNELIUS INC Page TABLE OF CONTENTSTROUBLESHOOTING TABLE OF CONTENTS cont’dPage FIGURE 1. FCB POST-MIX DISPENSERS WITH V4 FEATURES TABLE OF CONTENTS cont’dFIGURE 2. CONTROL PANEL SWITCH IDENTIFICATION WARRANTY312030002 THIS PAGE LEFT BLANK INTENTIONALLYRecognize Safety Information SAFETY INFORMATIONUnderstand Signal Words Follow Safety Instructions312030002 THIS PAGE LEFT BLANK INTENTIONALLYOPERATOR’S INSTRUCTIONS CONTROL PANEL SWITCHESCONTROL PANEL KEYPAD SECURITY ‘‘BLEND ON/OFF’’ Switches ‘‘SYRUP PRIME’’ Switches‘‘MOTOR’’ Switches ’’ON’’ SwitchesFIGURE 3. OPERATING CONTROLS FOUR-FLAVOR UNIT SHOWN ‘‘ERROR 1’’ and ‘‘ERROR 2’’ Fault Messages ‘‘FILL 1’’ and ‘‘FILL 2’’ Fault Messages‘‘OFF 1’’ and ‘‘OFF 2’’ Fault Messages ‘‘H2O OUT’’ Fault MessageUNITS EQUIPPED WITH HOT-GAS DEFROST SYSTEMS DEFROST SYSTEMSUNITS EQUIPPED WITH ELECTRIC DEFROST SYSTEMS ‘‘WAKE UP’’ WAKE UP TIME ‘‘SLEEP’’ SLEEP TIMEFACEPLATE RELIEF VALVES DISPENSING VALVES‘‘OVERRUN’’, AS APPLIED TO FROZEN CARBONATED BEVERAGES DISPENSED PRODUCT CONDITIONSADJUSTING CO2 REGULATORS OPERATING CHARACTERISTICSOPERATING UNIT PRIMARY CO2 REGULATORREPLENISHING SYRUP SUPPLY ADJUSTING BRIX WATER-TO-SYRUP “RATIO” OF DISPENSED PRODUCTSECONDARY CO2 REGULATORS SYRUP TANKS SYSTEMREPLENISHING CO2 SUPPLY SYRUP FLAVOR CHANGEBAG-IN-BOX SYSTEM DAILY CLEANING OF UNIT CLEANING AND SANITIZINGSANITIZING SYRUP SYSTEMS 10. Syrup Tank Syrup System WARNING Flush residual sanitizing solution from the syrup system as instructed. Residual sanitizing solution left in the syrup system could create a health hazard UNIT WITH AIR-COOLED REFRIGERATION SYSTEM CLEANING CONDENSER COILUNIT WITH REMOTE CONDENSING REFRIGERATION TROUBLESHOOTING TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATORS TROUBLESHOOTING DISPENSED PRODUCT NOTE DEFROST AFFECTED FREEZE CYLINDER AS INSTRUCTED IMI Cornelius Offices WARRANTYLD004 4/21/98 312030002Page IMI CORNELIUS INC CORPORATE HEADQUARTERS One Cornelius Place Anoka, Minnesota