Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius R-404A manual Operating Controls Four-Flavor Unit Shown

Models: R-404A

1 28

Download 28 pages 1.64 Kb

Page 10

FIGURE 3. OPERATING CONTROLS (FOUR-FLAVOR UNIT SHOWN)

TOP PANEL

CONTROL PANEL (2)

(SEE FIGURE 2)

FACEPLATE RELIEF

VALVE (4)

CUP REST

DRIP TRAY

CONDENSER COIL

ACCESS PANEL

NOTE: Two-flavor Unit- The No. 1 freeze cylinder is the left-hand cylinder facing the front of the Unit. No. 2 freeze cylinder is to the right of No. 1 freeze cylinder.

Four-flavor Unit- The No. 1 freeze cylinder is the left-hand cylinder facing the front of the Unit. The other three freeze cylinders, to the right of No. 1 freeze cylinder, are labeled 2, 11, and 22.

BACK PANEL

FACEPLATE (4)

DISPENSING

VALVE (4)

SIDE PANEL (2)

VENTILATION LOUVERS

FIGURE 3. OPERATING CONTROLS (FOUR-FLAVOR UNIT SHOWN)

5

312030002

Image 10

Cornelius R-404A manual Operating Controls Four-Flavor Unit Shown

Contents

Operator’s Manual FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT IMI CORNELIUS INC TABLE OF CONTENTS PageTROUBLESHOOTING TABLE OF CONTENTS cont’dPage FIGURE 2. CONTROL PANEL SWITCH IDENTIFICATION TABLE OF CONTENTS cont’dFIGURE 1. FCB POST-MIX DISPENSERS WITH V4 FEATURES WARRANTYTHIS PAGE LEFT BLANK INTENTIONALLY 312030002Understand Signal Words SAFETY INFORMATIONRecognize Safety Information Follow Safety InstructionsTHIS PAGE LEFT BLANK INTENTIONALLY 312030002OPERATOR’S INSTRUCTIONS CONTROL PANEL SWITCHESCONTROL PANEL KEYPAD SECURITY ‘‘MOTOR’’ Switches ‘‘SYRUP PRIME’’ Switches‘‘BLEND ON/OFF’’ Switches ’’ON’’ SwitchesFIGURE 3. OPERATING CONTROLS FOUR-FLAVOR UNIT SHOWN ‘‘OFF 1’’ and ‘‘OFF 2’’ Fault Messages ‘‘FILL 1’’ and ‘‘FILL 2’’ Fault Messages‘‘ERROR 1’’ and ‘‘ERROR 2’’ Fault Messages ‘‘H2O OUT’’ Fault MessageUNITS EQUIPPED WITH HOT-GAS DEFROST SYSTEMS DEFROST SYSTEMSUNITS EQUIPPED WITH ELECTRIC DEFROST SYSTEMS FACEPLATE RELIEF VALVES ‘‘SLEEP’’ SLEEP TIME‘‘WAKE UP’’ WAKE UP TIME DISPENSING VALVESDISPENSED PRODUCT CONDITIONS ‘‘OVERRUN’’, AS APPLIED TO FROZEN CARBONATED BEVERAGESOPERATING UNIT OPERATING CHARACTERISTICSADJUSTING CO2 REGULATORS PRIMARY CO2 REGULATORSECONDARY CO2 REGULATORS ADJUSTING BRIX WATER-TO-SYRUP “RATIO” OF DISPENSED PRODUCTREPLENISHING SYRUP SUPPLY SYRUP TANKS SYSTEMREPLENISHING CO2 SUPPLY SYRUP FLAVOR CHANGEBAG-IN-BOX SYSTEM DAILY CLEANING OF UNIT CLEANING AND SANITIZINGSANITIZING SYRUP SYSTEMS 10. Syrup Tank Syrup System WARNING Flush residual sanitizing solution from the syrup system as instructed. Residual sanitizing solution left in the syrup system could create a health hazard UNIT WITH AIR-COOLED REFRIGERATION SYSTEM CLEANING CONDENSER COILUNIT WITH REMOTE CONDENSING REFRIGERATION TROUBLESHOOTING TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATORS TROUBLESHOOTING DISPENSED PRODUCT NOTE DEFROST AFFECTED FREEZE CYLINDER AS INSTRUCTED LD004 4/21/98 WARRANTYIMI Cornelius Offices 312030002Page One Cornelius Place Anoka, Minnesota IMI CORNELIUS INC CORPORATE HEADQUARTERS