Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius R-404A manual Cleaning Condenser Coil, Unit With Air-Cooled Refrigeration System

Models: R-404A

1 28

Download 28 pages 1.64 Kb

Page 21

32.After carbonator water pump cycles off, intermittently pull and release the No. 1 freeze cylinder faceplate relief valve. This bleeds CO2 from the freeze cylinder and allows product to enter and fill the cylinder.

33.Open No. 2 product blender tank product shutoff valve.

CLEANING CONDENSER COIL

UNIT WITH AIR-COOLED REFRIGERATION SYSTEM

Circulating air, required to to cool the refrigeration system condenser coil, is drawn in through louvers on front and is exhausted out through louvers on sides and back of the Unit. MAKE SURE THE LOUVERS ARE NOT OBSTRUCTED. RESTRICTING AIR CIRCULATION THROUGH THE UNIT WILL DECREASE IT’S COOLING EFFICIENCY. The condenser coil air filter and the condenser coil must be periodically cleaned by a qualified Service Person.

UNIT WITH REMOTE CONDENSING REFRIGERATION

The Remote Condensing Unit, connected to the Dispenser is equipped with a condenser coil that must be cleaned every 30-days by a qualified Service Person. MAKE SURE THE REMOTE CONDENSING UNIT CON-

DENSER COIL IS FREE FROM DEBRIS. RESTRICTING AIR CIRCULATION THROUGH THE CONDENSER COIL WILL DECREASE THE CONDENSING UNIT’S COOLING EFFICIENCY.

312030002

16

Image 21

Cornelius R-404A manual Cleaning Condenser Coil, Unit With Air-Cooled Refrigeration System

Contents

FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT Operator’s Manual IMI CORNELIUS INC Page TABLE OF CONTENTSTABLE OF CONTENTS cont’d TROUBLESHOOTINGPage FIGURE 1. FCB POST-MIX DISPENSERS WITH V4 FEATURES TABLE OF CONTENTS cont’dFIGURE 2. CONTROL PANEL SWITCH IDENTIFICATION WARRANTY312030002 THIS PAGE LEFT BLANK INTENTIONALLYRecognize Safety Information SAFETY INFORMATIONUnderstand Signal Words Follow Safety Instructions312030002 THIS PAGE LEFT BLANK INTENTIONALLYCONTROL PANEL SWITCHES OPERATOR’S INSTRUCTIONSCONTROL PANEL KEYPAD SECURITY ‘‘BLEND ON/OFF’’ Switches ‘‘SYRUP PRIME’’ Switches‘‘MOTOR’’ Switches ’’ON’’ SwitchesFIGURE 3. OPERATING CONTROLS FOUR-FLAVOR UNIT SHOWN ‘‘ERROR 1’’ and ‘‘ERROR 2’’ Fault Messages ‘‘FILL 1’’ and ‘‘FILL 2’’ Fault Messages‘‘OFF 1’’ and ‘‘OFF 2’’ Fault Messages ‘‘H2O OUT’’ Fault MessageDEFROST SYSTEMS UNITS EQUIPPED WITH HOT-GAS DEFROST SYSTEMSUNITS EQUIPPED WITH ELECTRIC DEFROST SYSTEMS ‘‘WAKE UP’’ WAKE UP TIME ‘‘SLEEP’’ SLEEP TIMEFACEPLATE RELIEF VALVES DISPENSING VALVES‘‘OVERRUN’’, AS APPLIED TO FROZEN CARBONATED BEVERAGES DISPENSED PRODUCT CONDITIONSADJUSTING CO2 REGULATORS OPERATING CHARACTERISTICSOPERATING UNIT PRIMARY CO2 REGULATORREPLENISHING SYRUP SUPPLY ADJUSTING BRIX WATER-TO-SYRUP “RATIO” OF DISPENSED PRODUCTSECONDARY CO2 REGULATORS SYRUP TANKS SYSTEMSYRUP FLAVOR CHANGE REPLENISHING CO2 SUPPLYBAG-IN-BOX SYSTEM CLEANING AND SANITIZING DAILY CLEANING OF UNITSANITIZING SYRUP SYSTEMS 10. Syrup Tank Syrup System WARNING Flush residual sanitizing solution from the syrup system as instructed. Residual sanitizing solution left in the syrup system could create a health hazard CLEANING CONDENSER COIL UNIT WITH AIR-COOLED REFRIGERATION SYSTEMUNIT WITH REMOTE CONDENSING REFRIGERATION TROUBLESHOOTING TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATORS TROUBLESHOOTING DISPENSED PRODUCT NOTE DEFROST AFFECTED FREEZE CYLINDER AS INSTRUCTED IMI Cornelius Offices WARRANTYLD004 4/21/98 312030002Page IMI CORNELIUS INC CORPORATE HEADQUARTERS One Cornelius Place Anoka, Minnesota