Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius R-404A manual

Models: R-404A

1 28

Download 28 pages 1.64 Kb

Page 27

Image 27

Cornelius R-404A manual

Contents

FCB POST-MIX DISPENSER WITH V4 FEATURES R-404A REFRIGERANT Operator’s Manual IMI CORNELIUS INC Page TABLE OF CONTENTSTABLE OF CONTENTS cont’d TROUBLESHOOTINGPage WARRANTY TABLE OF CONTENTS cont’dFIGURE 1. FCB POST-MIX DISPENSERS WITH V4 FEATURES FIGURE 2. CONTROL PANEL SWITCH IDENTIFICATION312030002 THIS PAGE LEFT BLANK INTENTIONALLYFollow Safety Instructions SAFETY INFORMATIONRecognize Safety Information Understand Signal Words312030002 THIS PAGE LEFT BLANK INTENTIONALLYCONTROL PANEL SWITCHES OPERATOR’S INSTRUCTIONSCONTROL PANEL KEYPAD SECURITY ’’ON’’ Switches ‘‘SYRUP PRIME’’ Switches‘‘BLEND ON/OFF’’ Switches ‘‘MOTOR’’ SwitchesFIGURE 3. OPERATING CONTROLS FOUR-FLAVOR UNIT SHOWN ‘‘H2O OUT’’ Fault Message ‘‘FILL 1’’ and ‘‘FILL 2’’ Fault Messages‘‘ERROR 1’’ and ‘‘ERROR 2’’ Fault Messages ‘‘OFF 1’’ and ‘‘OFF 2’’ Fault MessagesDEFROST SYSTEMS UNITS EQUIPPED WITH HOT-GAS DEFROST SYSTEMSUNITS EQUIPPED WITH ELECTRIC DEFROST SYSTEMS DISPENSING VALVES ‘‘SLEEP’’ SLEEP TIME‘‘WAKE UP’’ WAKE UP TIME FACEPLATE RELIEF VALVES‘‘OVERRUN’’, AS APPLIED TO FROZEN CARBONATED BEVERAGES DISPENSED PRODUCT CONDITIONSPRIMARY CO2 REGULATOR OPERATING CHARACTERISTICSADJUSTING CO2 REGULATORS OPERATING UNITSYRUP TANKS SYSTEM ADJUSTING BRIX WATER-TO-SYRUP “RATIO” OF DISPENSED PRODUCTREPLENISHING SYRUP SUPPLY SECONDARY CO2 REGULATORSSYRUP FLAVOR CHANGE REPLENISHING CO2 SUPPLYBAG-IN-BOX SYSTEM CLEANING AND SANITIZING DAILY CLEANING OF UNITSANITIZING SYRUP SYSTEMS 10. Syrup Tank Syrup System WARNING Flush residual sanitizing solution from the syrup system as instructed. Residual sanitizing solution left in the syrup system could create a health hazard CLEANING CONDENSER COIL UNIT WITH AIR-COOLED REFRIGERATION SYSTEMUNIT WITH REMOTE CONDENSING REFRIGERATION TROUBLESHOOTING TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATORS TROUBLESHOOTING DISPENSED PRODUCT NOTE DEFROST AFFECTED FREEZE CYLINDER AS INSTRUCTED 312030002 WARRANTYIMI Cornelius Offices LD004 4/21/98Page IMI CORNELIUS INC CORPORATE HEADQUARTERS One Cornelius Place Anoka, Minnesota