Manuals / Country Home Products / Lawn and Garden / Tiller

Country Home Products ROTO-HOGTM Axle Hold Down Brackets, Figure Valve Stem, Cotter Pin Legs

Models: ROTO-HOGTM

1 54

Page 19

Axle Hold Down Brackets	2-Bolts each side

Figure 7

Push to lower the unit

(raise the Axles)

Figure 8

Valve Stem

Cotter Pin Legs	Flat Wheel Washer
Cotter Pin Legs
spread apart

Figure 9

CALL TOLL FREE 1-800-DR-OWNER

Page 19

Image 19

Country Home Products ROTO-HOGTM Axle Hold Down Brackets, Figure Push to lower the unit raise the Axles, Figure Valve Stem

Contents

SAFETY & OPERATING INSTRUCTIONS DR ROTO-HOGPOWER TILLERThanks once again for all of us at Table of Contents PARTS LISTS, SCHEMATIC DIAGRAMS AND WARRANTY NOTE: This information may be helpful to you INTRODUCING THE DR ROTO-HOGPOWER TILLERCHAPTER Conventions used in this manualDR ROTO-HOGPOWER TILLER Specification Sheet Labels GENERAL SAFETY RULESCHAPTER 4 DR ROTO-HOGPOWER TILLER CALL TOLL-FREE 1-800-DR-OWNER Protecting Yourself and Those Around YouSlope Operation Safety for ChildrenCALL TOLL-FREE 1-800-DR-OWNER Safety with Gasoline-PoweredMachines8 DR ROTO-HOGPOWER TILLER General SafetyAdditional Information and Potential Changes A Note to All UsersCALL TOLL-FREE 1-800-DR-OWNER 10 DR ROTO-HOGPOWER TILLER CHAPTER SETTING UP YOUR DR ROTO-HOGPOWER TILLER1-800-DR-OWNER Electric-StarterSwitch Control Box DR ROTO-HOGPOWER TILLER Controls and FeaturesManual Recoil Start Handle Battery Oil Fill OPTIONAL Spreader ON-OFFSwitchOpening the Shipping Carton Unpacking and Assembling the MachineTerminal Fuse Location in Front of Battery4 Pins NegativeCotter Pin Legs Axle Hold Down BracketsFigure Push to lower the unit raise the Axles Figure Valve StemAbout the Battery Charging the BatteryExtra Wire 2.Plug the Charger into a standard wall outlet Charging the BatteryCapacities Adding the Engine Oil and GasolineOil Fill Air FilterChoke Fuel Shut-Off Throttle Recoil Starter Handleentering the Tines during Attaching the DR ROTO-HOGPOWER TILLER Control Boxup or down. The lower the front of the frame, the deeper the Tine depth forOperator Controls OPERATING YOUR DR ROTO-HOGPOWER TILLERCHAPTER Manual Starting Before Starting the EngineStopping the Engine Electric StartingStarter Key Switch Figure 24 DR ROTO-HOGPOWER TILLER Operating SafetyU-Bolt*for Hanging the Control Box Understanding the Control BoxFigure Gardens Operating ProceduresOperating Parameters Food Plot Installation and Sod BustingCultivating Tips Tilling TipsHandling and Transporting Slopes and Uneven Terrain28 DR ROTO-HOGPOWER TILLER Procedure MAINTAINING THE DR ROTO-HOGPOWER TILLERRegular Maintenance Checklist NOTE: 1st time 5 hrsLubrication Removing and Replacing the Engine Oil Charging the Battery Battery CareRecycling a Used Battery Disposing of the Battery ResponsiblyRemoving and Replacing the V-Belt Tine Operation Check Tine Shear PinsEnd of Season and Storage CHAPTER TROUBLESHOOTINGTroubleshooting Table Recoil will not pull out or is difficult to pullThe Engine lacks power or is not running smoothly The Engine will not start using Electric- Start⇒Check the oil level and adjust as needed The Engine runs well but labors when tillingEngine smokes The Engine runs well but the Tines won’t moveParts List - Main Assembly PARTS LISTS, SCHEMATIC DIAGRAMS AND WARRANTYCHAPTER 070718 Schematic Diagram - Main AssemblyCALL TOLL FREE 1-800-DR-OWNER Ref# Part# Parts List -TineDrive Transmission AssemblyDescription CALL TOLL FREE 1-800-DR-OWNER 070718Parts List - Axle Assembly 070718 Schematic Diagram - Axle AssemblyCALL TOLL FREE 1-800-DR-OWNER 46 DR ROTO-HOGPOWER TILLER Wiring Diagram - Manual Start model070725 070725 Wiring Diagram - Electric-StartmodelCALL TOLL FREE 1-800-DR-OWNER 48 DR ROTO-HOGPOWER TILLER Notes2-YearLimited Warranty DR ROTO-HOG POWER TILLERCustomer Service Hotline Terms and ConditionsQuick Tilling Tips Daily Checklist for the DR ROTO-HOGPOWER TILLER

Axle Hold Down Brackets

2-Bolts each side

Figure 7

Figure 8

Cotter Pin Legs

Flat Wheel Washer

spread apart