Glossary, Accessories, Duty Cycle | Craftsman 919.19541 guide

GLOSSARY

Become familiar with these terms before operating the unit.

CFM: Cubic feet per minute.

SCFM: Standard cubic feet per minute; a unit of measure of air deliv- ery.

PSIG: Pounds per square inch gauge; a unit of measure of pressure. Code Certification: Products that bear one or more of the following marks: UL, CUL, ETL, CETL, have been evaluated by OSHA certified independent safety laboratories and meet the applicable Underwriters Laboratories Standards for Safety. Cut-In Pressure: While the motor is off, air tank pressure drops as you continue to use your accessory.

When the tank pressure drops to a certain low level the motor will restart automatically. The low pressure at which the motor automatically restarts is called “cut-in” pressure. Cut-Out Pressure: When an air compressor is turned on and begins to run, air pressure in the air tank begins to build. It builds to a certain high pressure before the motor auto- matically shuts off, protecting your air tank from pressure higher than its capacity. The high pressure at which the motor shuts off is called “cut-out” pressure.

Branch Circuit: Circuit carrying elec- tricity from electrical panel to outlet.

ACCESSORIES

This unit is capable of powering the following Accessories. The accessories are available through the current Power and Hand Tool Catalog or full-line Sears stores.

	Accessories		• Oil Fog Lubricators
	•	In Line Filter	• Air Hose:1/4", 3/8" or 1/2" inside
	•	Tire Air Chuck	diameter in various lengths
	• Quick Connector Sets (various		Refer to the selection chart located
		sizes)	Refer to the selection chart located
		sizes)	on the unit to select the tools this unit
	•	Air Pressure Regulators	on the unit to select the tools this unit
	•	Air Pressure Regulators	is capable of powering.

DUTY CYCLE

This air compressors should be oper- ated on not more than a 50% duty cycle. This means an air compressor that pumps air more than 50% of one hour is considered misuse, because

the air compressor is undersized for the required air demand. Maximum compressor pumping time per hour is 30 minutes for a 50% duty cycle.

9- ENG

D24910

Image 9

Craftsman 919.19541 owner manual Glossary, Accessories, Duty Cycle

Contents

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A AIR Compressor Table of Contents Specification Table Safety Guidelines DefinitionsImportant Safety Instructions What Could Happen Hazard Attachments & Accessories Hazard Belt can cause serious injury if they Never operate the compressor with Fire, Inhalation, Damage to Vehicle Surfaces Accessories AccessoriesGlossary Duty Cycle Contents of Carton AssemblyTools Required for Assembly To Install Handle To Assemble Wheels Assemble Rubber FeetTo Add Oil To Pump To Add Oil InstallationAir Compressor Location Before removing the oil fill cap or oil drain plug Voltage and Circuit Protection Extension Cords Know Your Air Compressor Operation Before First Start-up How to Use Your Unit How to StopBreak-in Instructions Pressure Release Valve Check Valve Before Each Start-Up How to Start Customer Responsibilities Maintenance To Drain Tank To Check Safety ValveOil Changing Air Filter Inspection Replacement Motor Pulley/Flywheel AlignmentAir Compressor Pump Intake and Exhaust Valves To Replace or Clean Check Valve Service and AdjustmentsOutlet Tube Pressure Relief Tube Nuts Nuts Check Valve Screwdriver Open position nothing is visible Pressure Switch Replacement MotorTo Replace Regulator To Replace Belt Regulator ArrowWing Nut Storage Problem Cause Correction Troubleshooting Pressure reading Minal box area Problem Cause Correction Garantía Contenido Modelo Nº 919-195410 Definiciones DE Normas DE SeguridadResultar en lesiones menores o Moderadas Guarde Estas Instrucciones Instrucciones Importantes DE Seguridad Agregados Y Accesorios Tros de acuerdo a los códigos eléctricos Advertencia Riesgo DE Quemaduras ¿QUÉ Puede OCURRIR? Advertencia Riesgo DE Operación Insegura ¿QUÉ Puede OCURRIR? Accesorios GlosarioCiclo DE Servicio Accesorios Contenido de la caja EnsambladoHerramientas necesarias para el ensamble Desempaque Ensamble de las patas de caucho Ensamble de las ruedasPara agregar aceite a la bomba Tuerca Para agregar aceite InstalaciónUbicación del compresor de aire Enchufe Protección del voltaje y del circuito Cables de extensión eléctrica Conozca su compresor de aire Operación Antes del primer arranque Cómo utilizar su unidadInstrucciones para el asentamiento Cómo detenerla Cómo poner en marcha Antes de cada puesta en marcha Responsabilidades del cliente Mantenimiento Aceite Cómo verificar la válvula de seguridadCómo drenar el tanque Verificación Polea y volante Alineación Filtro de Aire Inspección y reemplazo Para reemplazar o limpiar la válvu La de retención Servicio Y AjustesTubo de salida Tuercas TuercasVálvula reguladora Para volver a arrancar MotorPara reemplazar el regulador Interruptor de presión Reemplazo Cambio de la correa Regulador FlechaTuerca mariposa Almacenaje Problema Causa Corrección Guía DE Diagnóstico DE Problemas Operación. Nota Ajuste la presión Retire y limpie, o reemplace 57- SP D24910 D24910 58- SP 59- SP D24910 Get it fixed, at your home or ours