Contents
VENTED PROPANE GAS HEATERS
OWNER’S OPERATION AND INSTALLATION MANUAL
Models GVR65BPA, GVR65PA, GVR50BPA, GVR50PA, GVR35PA
SECTION
CONTENTS
PAGE
DANGER
SAFETY
INFORMATION
IMPORTANT Read this owner’s manual carefully and completely before
WARNINGS Continued
SAFETY INFORMATION
Continued
Figure 1 - Vented Propane Gas Heater, Radiant Front
PRODUCT
IDENTIFICATION
Figure 2 - Vented Propane Gas Heater, Rear View
LOCAL CODES
FEATURES
INSTALLING
UNPACKING
For convenience and efficiency, install heater
INSTALLING HEATER
Never install the heater
If you install the heater in a home garage
Continued
INSTALLING HEATER
When venting this heater, follow the safety information listed below
VENTING HEATER
Do not vent heater in any of the following ways see Figure
INSTALLING HEATER
Continued
Continued
VENTING HEATER continued Proper Size Vent
INSTALLING HEATER
Continued
Vent Types
plied. Install the external regulator between the heater
INSTALLING
A qualified service person must connect heater to gas
HEATER
Continued
INSTALLING HEATER
Use pipe joint sealant that is resistant to liquid petro- leum LP gas
Make sure external regulator has been installed be
INSTALLING
Test all gas piping and connections for leaks after install
Connecting to Gas Supply , page
Continued
INSTALLING HEATER
INSTALLING RADIANTS
Figure 9 - Location of Radiants
Continued
INSTALLING
HEATER
Glass panels may have sharp edges. Handle with care
Continued
INSTALLING HEATER
8. Repeat steps 4 through 7 for all glass panels
Carbon monoxide poisoning may lead to death
AIR FOR COMBUSTION AND VENTILATION
DANGER
Continued
COMBUSTION
AIR FOR
VENTILATION
Continued
VENTILATION
if attic has a thermostat controlled power vent
AIR FOR
COMBUSTION
VENTILATION
A confined area has an air volume of less than 50 cubic
AIR FOR
COMBUSTION
explosion may result causing property damage, per
OPERATING
vise young children when they are in the same room as
HEATER
Continued
OPERATING HEATER
Do not try to adjust heating levels by using the manual shutoff valve
Figure 18 - Viewing Pilot
Continued
MANUAL LIGHTING PROCEDURE
OPERATING HEATER
BLOWER OPERATION
PILOT FLAME PATTERN
INSPECTING PILOT AND BURNER FLAME
BURNER FLAME PATTERN
Continued
see Troubleshooting, pages 27 through
INSPECTING PILOT AND BURNER FLAME
100791
Turn off heater and let cool before cleaning or servicing
CLEANING
MAINTENANCE
passageways of heater clean. Inspect these areas of
Unless you need gas supply for testing, shut off manual
TROUBLE
SHOOTING
shutoff valve before servicing. Only a qualified service
Cleaning and Mainte
TROUBLE- SHOOTING
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
Cleaning and Mainte
PROBLEM
Cleaning and Mainte
TROUBLE- SHOOTING
TROUBLE
PROBLEM
ing and Maintenance
SHOOTING
SERVICE PROCEDURES
Removing Control Valve and Burner Tube
Removing Burner
SERVICE PROCEDURES
Continued
Continued
WIRING
SERVICE
PROCEDURES
DIAGRAM
SPECIFICATIONS
TECHNICAL SERVICE
SERVICE HINTS
35,000 BTU/Hr
PARTS
REPLACEMENT
ORDERING
CENTRALS
100791
ACCESSORIES
VALVE - GA5010
MANUAL SHUTOFF
ILLUSTRATED PARTS LIST Blower Assembly
ILLUSTRATED PARTS LIST Cabinet Assembly for Radiant Models
ILLUSTRATED
PARTS LIST
Assembly for
Burner
PARTS LIST Burner Assembly for Radiant Models
Thermocouple Interrupter
100791
100791
WARRANTY INFORMATION
LIMITED WARRANTY GVR/GVC VENTED PROPANE GAS HEATERS