Contents
Models GVR65BPA, GVR65PA, GVR50BPA, GVR50PA, GVR35PA
OWNER’S OPERATION AND INSTALLATION MANUAL
VENTED PROPANE GAS HEATERS
PAGE
CONTENTS
SECTION
IMPORTANT Read this owner’s manual carefully and completely before
SAFETY
INFORMATION
DANGER
Continued
SAFETY INFORMATION
WARNINGS Continued
Figure 2 - Vented Propane Gas Heater, Rear View
PRODUCT
IDENTIFICATION
Figure 1 - Vented Propane Gas Heater, Radiant Front
UNPACKING
FEATURES
INSTALLING
LOCAL CODES
If you install the heater in a home garage
INSTALLING HEATER
Never install the heater
For convenience and efficiency, install heater
VENTING HEATER
INSTALLING HEATER
When venting this heater, follow the safety information listed below
Continued
Continued
INSTALLING HEATER
Continued
Do not vent heater in any of the following ways see Figure
Vent Types
INSTALLING HEATER
Continued
VENTING HEATER continued Proper Size Vent
HEATER
INSTALLING
A qualified service person must connect heater to gas
plied. Install the external regulator between the heater
Use pipe joint sealant that is resistant to liquid petro- leum LP gas
INSTALLING HEATER
Continued
Connecting to Gas Supply , page
INSTALLING
Test all gas piping and connections for leaks after install
Make sure external regulator has been installed be
Figure 9 - Location of Radiants
INSTALLING HEATER
INSTALLING RADIANTS
Continued
Glass panels may have sharp edges. Handle with care
INSTALLING
HEATER
Continued
8. Repeat steps 4 through 7 for all glass panels
INSTALLING HEATER
Continued
Continued
AIR FOR COMBUSTION AND VENTILATION
DANGER
Carbon monoxide poisoning may lead to death
Continued
AIR FOR
VENTILATION
COMBUSTION
COMBUSTION
if attic has a thermostat controlled power vent
AIR FOR
VENTILATION
COMBUSTION
A confined area has an air volume of less than 50 cubic
AIR FOR
VENTILATION
HEATER
OPERATING
vise young children when they are in the same room as
explosion may result causing property damage, per
Figure 18 - Viewing Pilot
OPERATING HEATER
Do not try to adjust heating levels by using the manual shutoff valve
Continued
BLOWER OPERATION
MANUAL LIGHTING PROCEDURE
OPERATING HEATER
Continued
BURNER FLAME PATTERN
INSPECTING PILOT AND BURNER FLAME
PILOT FLAME PATTERN
100791
see Troubleshooting, pages 27 through
INSPECTING PILOT AND BURNER FLAME
Continued
passageways of heater clean. Inspect these areas of
CLEANING
MAINTENANCE
Turn off heater and let cool before cleaning or servicing
shutoff valve before servicing. Only a qualified service
TROUBLE
SHOOTING
Unless you need gas supply for testing, shut off manual
Cleaning and Mainte
TROUBLE- SHOOTING
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
TROUBLE- SHOOTING
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
SHOOTING
PROBLEM
ing and Maintenance
TROUBLE
Removing Control Valve and Burner Tube
SERVICE PROCEDURES
Continued
SERVICE PROCEDURES
Continued
Removing Burner
DIAGRAM
SERVICE
PROCEDURES
WIRING
35,000 BTU/Hr
TECHNICAL SERVICE
SERVICE HINTS
SPECIFICATIONS
CENTRALS
REPLACEMENT
ORDERING
PARTS
MANUAL SHUTOFF
ACCESSORIES
VALVE - GA5010
100791
ILLUSTRATED PARTS LIST Blower Assembly
ILLUSTRATED PARTS LIST Cabinet Assembly for Radiant Models
Burner
PARTS LIST
Assembly for
ILLUSTRATED
Thermocouple Interrupter
PARTS LIST Burner Assembly for Radiant Models
100791
100791
LIMITED WARRANTY GVR/GVC VENTED PROPANE GAS HEATERS
WARRANTY INFORMATION