Contents
VENTED PROPANE GAS HEATERS
OWNER’S OPERATION AND INSTALLATION MANUAL
Models GVR65BPA, GVR65PA, GVR50BPA, GVR50PA, GVR35PA
SECTION
CONTENTS
PAGE
INFORMATION
SAFETY
DANGER
IMPORTANT Read this owner’s manual carefully and completely before
WARNINGS Continued
SAFETY INFORMATION
Continued
IDENTIFICATION
PRODUCT
Figure 1 - Vented Propane Gas Heater, Radiant Front
Figure 2 - Vented Propane Gas Heater, Rear View
INSTALLING
FEATURES
LOCAL CODES
UNPACKING
Never install the heater
INSTALLING HEATER
For convenience and efficiency, install heater
If you install the heater in a home garage
When venting this heater, follow the safety information listed below
INSTALLING HEATER
Continued
VENTING HEATER
Continued
INSTALLING HEATER
Do not vent heater in any of the following ways see Figure
Continued
Continued
INSTALLING HEATER
VENTING HEATER continued Proper Size Vent
Vent Types
A qualified service person must connect heater to gas
INSTALLING
plied. Install the external regulator between the heater
HEATER
Continued
INSTALLING HEATER
Use pipe joint sealant that is resistant to liquid petro- leum LP gas
Test all gas piping and connections for leaks after install
INSTALLING
Make sure external regulator has been installed be
Connecting to Gas Supply , page
INSTALLING RADIANTS
INSTALLING HEATER
Continued
Figure 9 - Location of Radiants
HEATER
INSTALLING
Continued
Glass panels may have sharp edges. Handle with care
Continued
INSTALLING HEATER
8. Repeat steps 4 through 7 for all glass panels
DANGER
AIR FOR COMBUSTION AND VENTILATION
Carbon monoxide poisoning may lead to death
Continued
VENTILATION
AIR FOR
COMBUSTION
Continued
AIR FOR
if attic has a thermostat controlled power vent
VENTILATION
COMBUSTION
AIR FOR
A confined area has an air volume of less than 50 cubic
VENTILATION
COMBUSTION
vise young children when they are in the same room as
OPERATING
explosion may result causing property damage, per
HEATER
Do not try to adjust heating levels by using the manual shutoff valve
OPERATING HEATER
Continued
Figure 18 - Viewing Pilot
OPERATING HEATER
MANUAL LIGHTING PROCEDURE
Continued
BLOWER OPERATION
PILOT FLAME PATTERN
INSPECTING PILOT AND BURNER FLAME
BURNER FLAME PATTERN
INSPECTING PILOT AND BURNER FLAME
see Troubleshooting, pages 27 through
Continued
100791
MAINTENANCE
CLEANING
Turn off heater and let cool before cleaning or servicing
passageways of heater clean. Inspect these areas of
SHOOTING
TROUBLE
Unless you need gas supply for testing, shut off manual
shutoff valve before servicing. Only a qualified service
PROBLEM
TROUBLE- SHOOTING
Cleaning and Mainte
Cleaning and Mainte
Cleaning and Mainte
PROBLEM
Cleaning and Mainte
Cleaning and Mainte
Cleaning and Mainte
PROBLEM
Cleaning and Mainte
TROUBLE- SHOOTING
ing and Maintenance
PROBLEM
TROUBLE
SHOOTING
Removing Control Valve and Burner Tube
SERVICE PROCEDURES
Continued
SERVICE PROCEDURES
Removing Burner
Continued
PROCEDURES
SERVICE
WIRING
DIAGRAM
SERVICE HINTS
TECHNICAL SERVICE
SPECIFICATIONS
35,000 BTU/Hr
ORDERING
REPLACEMENT
PARTS
CENTRALS
VALVE - GA5010
ACCESSORIES
100791
MANUAL SHUTOFF
ILLUSTRATED PARTS LIST Blower Assembly
ILLUSTRATED PARTS LIST Cabinet Assembly for Radiant Models
Assembly for
PARTS LIST
ILLUSTRATED
Burner
Thermocouple Interrupter
PARTS LIST Burner Assembly for Radiant Models
100791
100791
LIMITED WARRANTY GVR/GVC VENTED PROPANE GAS HEATERS
WARRANTY INFORMATION