INSTALLING | CHECKING GAS CONNECTIONS | |||
HEATER |
| WARNING ICONG 001WARNING | ||
Continued |
| Test all gas piping and connections for leaks after install- |
| |
|
| ing or servicing. Correct all leaks at once. | ||
|
|
|
|
|
|
|
|
| |
|
| WARNING ICONG 001WARNING | ||
|
| Never use an open flame to check for a leak. Apply a |
| |
|
| mixture of liquid soap and water to all joints. Bubbles | ||
|
| forming show a leak. Correct all leaks at once. | ||
|
|
|
| |
|
|
| ||
|
| WARNING ICONG 001CAUTION | ||
|
| Make sure external regulator has been installed be- |
| |
|
| tween propane supply and heater. See guidelines under | ||
|
| Connecting to Gas Supply, page 11. | ||
|
|
|
|
|
Pressure Testing Gas Supply Piping System
Test Pressures In Excess of 1/2 PSIG
1.Disconnect heater and its individual manual shutoff valve from gas supply pipe. Pressures in excess of 1/2 PSIG will damage heater regulator.
2.Cap off open end of gas pipe where manual shutoff valve was connected.
3.Pressurize supply piping system by either using compressed air or opening propane supply tank valve.
4.Check all joints of gas supply piping system. Apply mixture of liquid soap and water to gas joints. Bubbles forming show a leak.
5.Correct all leaks at once.
6.
Test Pressures Equal To or Less Than 1/2 PSIG
1.Close manual shutoff valve (see Figure 8).
2.Pressurize supply piping system by either using compressed air or opening propane supply tank valve.
3.Check all joints from propane supply tank to manual shutoff valve. Apply mixture of liquid soap and water to gas joints. Bubbles forming show a leak.
4.Correct all leaks at once.
Pressure Testing Heater Gas Connections
1.Open manual shutoff valve (see Figure 8).
2.Open propane supply tank valve.
3.Make sure control knob of heater is in the OFF position.
4.Check all joints from manual shutoff valve to control valve on heater. Apply mixture of liquid soap and water to gas joints. Bubbles forming show a leak.
5.Correct all leaks at once.
6.Light heater (see Operating Heater, pages 21 through 23). Check the rest of the internal joints for leaks.
7.Turn off heater (see To Turn Off Gas to Appliance, page 23).
PO On Position
Off Position | Continued | |
Figure 8 - Manual Shutoff Valve |
|
|
| 13 | |
| ||
|
|
|
100791
