Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster BIH1721, FPH1721 operation manual Operating the Filter

Models: FPH1721 BIH1721

1 37

Download 37 pages 49.26 Kb

Page 22

4.3 Operating the Filter

EH1721 SERIES ELECTRIC FRYERS

CHAPTER 4: BUILT-IN FILTRATION

4.2.2 Filtering Tools

The following tools are not required, but are recommended to make the filtering task easier.

•Measuring Cup — used to measure filter powder.

•Stainless Steel Crumb Scoop — for removing large debris.

Note: Always wear oil-resistant, insulated gloves and/or protective gear when working with hot oil.

4.3 Operating the Filter

4.3.1 Pan Preparation

1.Pull the filter pan outward until the slip fitting disconnects. Allow any residual oil left in the fittings to drip into the pan. Remove the filter pan from fryer cabinet. Use caution and wear protective gear.

Pull the filter pan from the fryer cabinet.

2. Remove both pan covers from the pan.

Pan covers removed from the pan.

4-3

Image 22

Frymaster BIH1721, FPH1721 operation manual Operating the Filter

Contents

8195713 EH1721, BIH1721 & FPH1721 SeriesEmail service@frymaster.com PRINTED IN THE UNITED STATESNOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S DANGER DANGERDANGER DANGERTABLE OF CONTENTS EH1721 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION 1.2 Safety InformationFryers in this series are equipped with automatic safety features 1.1 GeneralEH1721 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION 1.4 Shipping Damage Claim Procedure1.3 Computer Information What to do if your equipment arrives damaged1.5 Service Information 1.6 After PurchaseC. Qualified Service Personnel 1.7 SERVICE PERSONNELB. Qualified Installation Personnel A. Qualified and/or Authorized Operating PersonnelFINDING YOUR WAY AROUND THE EH1721 SERIES ELECTRIC FRYER EH1721 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONSconfiguration and date of manufacture 2.1 General EH1721 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONS2.1.2 Electrical Grounding Requirements 2.2 Fryer Installation 2.1.3 Australian Requirements2.3 Power Requirements 2.4 Frypot Boil Out Setup 2.5 Equipment Setup and Shutdown ProceduresShutdown 3.1 Cleaning Fryer EH1721 SERIES ELECTRIC FRYERS CHAPTER 3 PREVENTATIVE MAINTENANCEBoiling Out the Frypot If your fryer is not equipped with a built-in filtration system Under Fryer Filter UFF, the oil must be drained into another suitable container. For safe, convenient draining and disposal of used oil or shortening, Frymaster recommends using the Frymaster Shortening Disposal Unit SDU. The SDU is available through your local distributor 3.2 Periodic/Annual Maintenance Built-in Filtration3.2 Periodic/Annual Maintenance cont 3.3 Stainless Steel CareEH1721 SERIES ELECTRIC FRYERS CHAPTER 4 BUILT-IN FILTRATION 4.1 Filtration Preparation4.2 Daily Filtration Operation 4.3 Operating the Filter 5. Place the filter paper over top of pan 6. Seat the filter paper with the hold-down ring, ensuring that the paper extends beyond all sides of the hold-down ring correct placement 2. Ensure the oil is at operating temperature and turn the fryer off 5. After all oil has drained from the frypot into the filter pan, pull the yellow handle to open the oil return lines and activate the filter pump 8. After all the oil is pumped back into the frypot, bubbles will form, indicating air in the oil return lines. Allow the oil to bubble for 4-10 Verify that frypot drain valves are fully closed EH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTING5.1 Introduction Before calling a service agent or the Frymaster Dean HOTLINE5.2.1 Control and Heating Problems 5.2 TroubleshootingEH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTING ProblemProbable Causes probe failure OPEN DRAINTEMP or HI-Temp properly. See Fryer Does Not Heat inPROBE FAILURE IgnitionFailure startProblem EH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTING5.2.4 Built-in Filtration Problems cont Probable CausesPart Number 5.3 Recommended Spare PartsDescription FAX Parts SERVICE HOTLINEShipping Address 8700 Line Avenue, Shreveport, Louisiana FAX Tech Support