Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster FPH1721, BIH1721 operation manual EH1721 SERIES ELECTRIC FRYERS INSTALLATION INSTRUCTIONS

Models: FPH1721 BIH1721

1 37

Download 37 pages 49.26 Kb

Page 9

EH1721 SERIES ELECTRIC FRYERS

EH1721 SERIES ELECTRIC FRYERS

CHAPTER 2: INSTALLATION INSTRUCTIONS

FINDING YOUR WAY AROUND THE EH1721 SERIES ELECTRIC FRYER

Flue Cap

Elements

Computer Panel

(CM4-S Computer

shown)

Fryer Identification

Data Label (Model and

Serial Number)

Basket Hangers

Top Cap

Drain and Filter Control

Handles

Under Fryer Filtration Unit

TYPICAL CONFIGURATION (FPH31721 SHOWN)

NOTE: The appearance of your fryer may differ slightly from that shown depending upon

configuration and date of manufacture.

2-1

Image 9

Frymaster FPH1721, BIH1721 EH1721 SERIES ELECTRIC FRYERS INSTALLATION INSTRUCTIONS, configuration and date of manufacture

Contents

Email service@frymaster.com EH1721, BIH1721 & FPH1721 Series8195713 PRINTED IN THE UNITED STATESNOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S DANGER DANGERDANGER DANGERTABLE OF CONTENTS Fryers in this series are equipped with automatic safety features 1.2 Safety InformationEH1721 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION 1.1 General1.3 Computer Information 1.4 Shipping Damage Claim ProcedureEH1721 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION What to do if your equipment arrives damaged1.6 After Purchase 1.5 Service InformationB. Qualified Installation Personnel 1.7 SERVICE PERSONNELC. Qualified Service Personnel A. Qualified and/or Authorized Operating PersonnelEH1721 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONS FINDING YOUR WAY AROUND THE EH1721 SERIES ELECTRIC FRYERconfiguration and date of manufacture EH1721 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONS 2.1 General2.1.2 Electrical Grounding Requirements 2.1.3 Australian Requirements 2.2 Fryer Installation2.3 Power Requirements 2.4 Frypot Boil Out 2.5 Equipment Setup and Shutdown Procedures SetupShutdown EH1721 SERIES ELECTRIC FRYERS CHAPTER 3 PREVENTATIVE MAINTENANCE 3.1 Cleaning FryerBoiling Out the Frypot If your fryer is not equipped with a built-in filtration system Under Fryer Filter UFF, the oil must be drained into another suitable container. For safe, convenient draining and disposal of used oil or shortening, Frymaster recommends using the Frymaster Shortening Disposal Unit SDU. The SDU is available through your local distributor Built-in Filtration 3.2 Periodic/Annual Maintenance3.3 Stainless Steel Care 3.2 Periodic/Annual Maintenance cont4.1 Filtration Preparation EH1721 SERIES ELECTRIC FRYERS CHAPTER 4 BUILT-IN FILTRATION4.2 Daily Filtration Operation 4.3 Operating the Filter 5. Place the filter paper over top of pan 6. Seat the filter paper with the hold-down ring, ensuring that the paper extends beyond all sides of the hold-down ring correct placement 2. Ensure the oil is at operating temperature and turn the fryer off 5. After all oil has drained from the frypot into the filter pan, pull the yellow handle to open the oil return lines and activate the filter pump 8. After all the oil is pumped back into the frypot, bubbles will form, indicating air in the oil return lines. Allow the oil to bubble for 4-10 5.1 Introduction EH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTINGVerify that frypot drain valves are fully closed Before calling a service agent or the Frymaster Dean HOTLINEEH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTING 5.2 Troubleshooting5.2.1 Control and Heating Problems ProblemProbable Causes TEMP or HI-Temp OPEN DRAINprobe failure properly. See Fryer Does Not Heat inFailure IgnitionPROBE FAILURE start5.2.4 Built-in Filtration Problems cont EH1721 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTINGProblem Probable Causes5.3 Recommended Spare Parts Part NumberDescription Shipping Address 8700 Line Avenue, Shreveport, Louisiana SERVICE HOTLINEFAX Parts FAX Tech Support