Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster H20.5 SERIES Part #, Component, 824-0594, Tilt Housing, 806-7713, 823-2555, Top Cap

Models: H20.5 SERIES

1 42

Page 36

6.6Control Panel Assemblies, Top Caps/Tilt Housings and Related Components

1	2
3	4

ITEM	PART #	COMPONENT
1	824-0594	Tilt Housing
2	806-7713	Control Panel Assembly
3	823-2555	Top Cap
4	823-2568	Support, Top Cap

6-6

Page 36

Image 36

Frymaster H20.5 SERIES Part #, Component, 824-0594, Tilt Housing, 806-7713, Control Panel Assembly, 823-2555, Top Cap

Contents

24-Hour Service Hotline Installation, Operation & Parts Manual8195606 JUNENOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S CANADADANGER DANGER DANGERDANGER DANGERSafety Information Shipping Damage Claim ProcedureINSTALLATION INSTRUCTIONS Fryer Installation1.2 Safety Information Fryers in this series are equipped with automatic safety featuresH20.5 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION 1.1 General1.4 Shipping Damage Claim Procedure 1.3 Computer InformationH20.5 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION What to do if your equipment arrives damaged1.5 Service Information 1.6 After PurchaseH20.5 SERIES ELECTRIC FRYERS CHAPTER 1 INTRODUCTION 1.7 SERVICE PERSONNEL B. Qualified Installation PersonnelC. Qualified Service Personnel 1.7.1 DefinitionsH20.5 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONS 2.1 Generalthis or any other appliance injury may result2.2 Fryer Installation H20.5 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONSDo not block the area around the base or under the fryers 2.3 Power Requirements 2.4 Frypot Boil Outand serial number plate located inside the fryer door DANGER H20.5 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONSON/OFF switch to the OFF position to control boil over H20.5 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONS4. Press computer ON/OFF switch to ON 2.5 Equipment Setup and Shutdown Procedures SetupShutdown H20.5 SERIES ELECTRIC FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONSH20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS 3.1 Operating Fryers with Computer Magic III.5 Computerswater. NEVER allow water to enter the Filtration System if applicable DESCRIPTION3.1.1 Equipment Setup and Shutdown Procedures 3.1 Operating Fryers with Computer Magic III.5 Computers contH20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS Setup3.1.1 Equipment Setup and Shutdown Procedures cont Do not cancel the melt cycle mode if using solid shorteningOperating the Fryer H20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS3.1.2 Checking Temperature 3.2 Programming The Computer Magic3.1.1 Equipment Setup and Shutdown Procedures cont H20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS3.2 Programming The Computer Magic III.5 cont H20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS3.2.1 Boil Feature 3.2.2 Fryer Recovery Time Check3.2.3 Temperature Selection-Fahrenheit to Celsius 3.2 Programming The Computer Magic III.5 cont3.2.4 Constant Oil Temperature Display Mode 3.2.5 In-N-Out Burger CMIII.5 Programming SpecificationsProgramming specifications for In-N-Out Burger CM-III.5 H20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONS3.3 Fallback Controller Optional H20.5 SERIES ELECTRIC FRYERS CHAPTER 3 OPERATING INSTRUCTIONSH20.5 SERIES ELECTRIC FRYERS CHAPTER 4 PREVENTATIVE MAINTENANCE 4.1 Cleaning Fryer4.1.1 Clean Inside and Outside of Fryer Cabinet- Daily 4.1.2 Clean Frypot and Heating Elements- Weekly4.1.4 Draining and Manual Filtering Non-Filtration Fryers DANGER appropriate container for disposaloil/shortening will rush out, creating an extreme hazard If your fryer is not equipped with a built-in filtration system FootPrint III or Filter Magic II, the cooking oil or shortening must be drained into another suitable container. For safe, convenient draining and disposal of used cooking oil or shortening, Frymaster recommends using the Frymaster Shortening Disposal Unit SDU. The SDU is available through your local distributorH20.5 SERIES ELECTRIC FRYERS CHAPTER 5 OPERATOR TROUBLESHOOTING 5.1 IntroductionVerify that frypot drain valves are fully closed Before calling a service agent or the Frymaster HOTLINE5.2 Troubleshooting 5.2.1 Control and Heating ProblemsProblem Probable Causes5.2.1 Control and Heating Problems cont ProblemCorrective Action Probable Causes5.2.2 Error Messages and Display Problems 5.2.1 Control and Heating Problems contProblem Problem5.2.2 Error Messages and Display Problems cont ProblemCorrective Action Probable Causes5.3 Wiring Diagrams 5.3.1 Wiring Diagram, Contactor5.3.2 Wiring Diagram, Main H20.5 SERIES ELECTRIC FRYERS CHAPTER 6 PARTS LIST 6.1 Cabinet Assemblies and Related Components6.1 Cabinet Assemblies and Component Parts cont 6.2 Casters and Associated HardwarePART # COMPONENT6.3 Component Box Assembly and Associated Hardware wires hereTo Computer Solder non-terminal6.3 Component Box Assembly and Associated Hardware cont 6.4 Contactor Box and Related ComponentsPART # COMPONENT6.4 Contactor Box and Related Components cont 6.5 Controller Assemblies807-0922 106-1207Tilt Housing Control Panel AssemblyPART # COMPONENT6.7 Frypot Assembly and Related Components 6.7 Frypot Assembly and Related Components cont PART #COMPONENT 6.8 Heating Elements and Related Components 6.8 Heating Elements and Related Components cont 6.9 Thermostats and Related ComponentsPART # COMPONENTTHIS PAGE INTENTIONALLY LEFT BLANK 8195606 SERVICE HOTLINEShipping Address 8700 Line Avenue, Shreveport, Louisiana FAX Parts

824-0594

Tilt Housing

806-7713

Control Panel Assembly

823-2555

Top Cap

823-2568

Support, Top Cap