Hardware User Manual
Managed Switch
Installation and User Guide
Magnum 6K32T & 6K32TRC
Trademarks
Magnum 6K32T & 6K32TRC Managed Switch Hardware
Installation and User Guide
www . GarrettCom . com
Fremont, CA
GarrettCom, Inc
47823Westinghouse Dr
Phone 510
INTRODUCTION
SPECIFICATIONS
INSTALLATION
OPERATION
APPENDIX A WARRANTY INFORMATION
5.0 6K32T & 6K32TRC MANAGED SWITCH PORT MODULES
TROUBLESHOOTING
APPENDIX B INTERNAL DC POWER SUPPLY OPTIONS
The “X-line” of configurable MiXed Media products
OVERVIEW
Personal Switches, 10/100Mb
The Magnum Line
Network Standards and Compliance
1.0 SPECIFICATIONS 1.1 Technical Specifications
Performance
Maximum 10 Mbps Ethernet Segment Lengths
Management Console connector
LC-type Small Form Factor SFF
Fiber connector types supported
Power Supply Internal
Fuse Required - 2Amps
Relay Alarm Contact Optional
Cooling Method
Fuse Required - 3Amps
1.2 Ordering Information
Magnum Managed Switch
MODEL DESCRIPTION
Configuration Options
www . GarrettCom . com
Gigabit Options Modules using GBIC
Modules with Gb, not using GBICs
NOTE For configuring in 6K Switches having AC /125VDC power input
6K32T/6K32TRC PoE Modules with 48VDC Power Inside
6K32T/6K32TRC PoE Modules with 48VDC Pass-Through
www . GarrettCom . com
www . GarrettCom . com
2.0 Introduction 2.1 Inspecting the Package and Product
www . GarrettCom . com
2.2 Product Description - Magnum 6K32TRC Managed Switch
www . GarrettCom . com
include SNMPv3, SSL/SSH, 802.1X, TACACS+, Port Security, and Tagged VLANs
www . GarrettCom . com
2.2.1a Magnum 6K32T Managed Switch Chassis
www . GarrettCom . com
2.2.2 Eight-port SFF fiber modules 6K8-MTRJ, 6K8-MLC, 100Mb fiber
www . GarrettCom . com
www . GarrettCom . com
2.2.3 Eight-Port Copper
Module, 6K8-RJ45 MDIX
PI6KP8V-45RJ
2.2.3a New PoEPower Inside, model PI6KP8-45RJ MDIX, 8-port 10/100Mb
www . GarrettCom . com
8 Port@ 10/100Mb POE Copper ports
4@RJ-45 + 2@ 100Mb ST or SC
www . GarrettCom . com
ports. The
2.2.5 Four-Port 10 Mb mm Fiber ST Modules
copper and 2@10Mb fiber mm ST
4@ RJ-45 + 2@ 10 Mb ST
1@ 1000Mb Fiber SC + 4@10/ 100Mb
2.2.6 Gigabit 1000Mbps port modules
1@ 1000Mb Fiber SC + 2@ 100Mb SC
www . GarrettCom . com
www . GarrettCom . com
2.2.7 Packet Prioritization, 802.1p QOS
2.2.8 Frame Buffering and Flow Control
MIBs for SNMP visit
2.2.9 Managed Network Software MNS-6K for Magnum 6K32T & 6K32TRC
For upgrading the Magnum 6K32T & 6K32TRC Switch to its latest
www . GarrettCom . com
Switching services includes 802.1p QoS packet prioritization
2.3 Features and Benefits
Managed switching for high performance Ethernet LANs
Features Fiber-Built-In
www . GarrettCom . com
2.4 Applications
Example 1 Magnum 6K32T Switch for a VLAN application
Data
www . GarrettCom . com
Internet
Example 3 Redundant Application 6K32TRC
www . GarrettCom . com
www . GarrettCom . com
Installation and User Guide 05/07
6K32TRC in a Redundant application
6K32TRC with IGMP-L2 mode
www . GarrettCom . com
Figure 3.1 Location of the Magnum 6K32T’s cooling fans
3.0 Installation
3.1 Locating Magnum 6K32T Switches
www . GarrettCom . com
1 mm = multi-mode
3.2 Connecting Ethernet Media
3.2.1 Connecting Fiber Optic ST-type, “twist-lock”
2 sgl.m = single-mode
Media
3.2.2 Connecting Fiber Optic SC-type, Snap-In
3.2.3 Connecting Single-Mode Fiber Optic
IEEE Standard
IEEE Standard
3.2.6 Gigabit SFP Small Form-factor Pluggable Optical Transceivers
Media
www . GarrettCom . com
Side View
TX Bail clasp
Duplex LC connector
Front view
www . GarrettCom . com
Fiber
6KP4
www . GarrettCom . com
Speed
Fig 3.3.1 Dual Side-Mountings for Magnum 6K32T & 6K32TRC units
3.3 Table-Top or Shelf Mounting
3.3.1 Rack-mounting for 19” RETMA racks, Magnum 6K32T & 6K32TRC’s
www . GarrettCom . com
Rear Mount
3.3.2 Rack-mounting, Reverse version of the Magnum 6K32T’s
www . GarrettCom . com
3.3.2 Reverse Magnum 6K32TRC units, rack-mounted in a frame
3.4 Powering the Magnum 6K32T & 6K32TRC Managed Switch
www . GarrettCom . com
STOP
3.5 6K32T & 6K32TRC Port Module 6KPM Installation
3.5.1 Preparation for Installing and Removing 6KPMs
and will void the warranty
www . GarrettCom . com
Step 2. Remove Chassis Cover
Figure 3.5.1a Removing front panel after the screws being removed
Step 3. Remove front panel face plate retaining screws
Caution Be careful not to disturb the power supply
Fig 3.5.1b Pulling out the top coved from the chassis base
www . GarrettCom . com
www . GarrettCom . com
3.5.2 Installing 6KPM Cards in the Magnum 6K32T & 6K32TRC
Figure 3.5.1d Top View - 6KPM retaining screws hold Face Plate
Fig 3.5.2d Daughter Board shown upside down with two male latch connectors
www . GarrettCom . com
6K32TRC Switch
NOTE. When leaving 6KPM slots empty, always use a face plate Magnum
Fig. 3.5.2g Top View 6KPM Module installed inside a 6K32T
Fig.3.5.2f Securely latching up 6KPM Cards into a
Figure 3.5.3a Top View
3.5.3 Removing 6KPM Cards
Caution Be sure the power cord is unplugged
6 retaining screws shown by arrows Step 3. Remove 6KPM Card
Rear View of Magnum 6K32T
Figure 3.5.3b Removing a 6KPM Card
Console DB-9 Port
www . GarrettCom . com
Description
Signal
3.6.1 RS-232 DB-9 Console Com port Serial port pin assignments
DB-9 Console port connector
Filtering and Forwarding
4.1 Switching Functionality
4.0 OPERATION
Address Learning
Power LED, ON when external power is applied to the unit
4.2 Status LEDs
4.3 Auto-Cross MDIXAuto-negotiation, for 10/100Mbps RJ-45 ports
Full / Half duplex LED, ON when the port is running full
Auto-negotiation per-port for 802.3u-compliant switches occurs when
www . GarrettCom . com
www . GarrettCom . com
5.0 Magnum 6K32T & 6K32TRC Managed Switch Port Modules
4.4 Flow-control, IEEE 802.3x standard
www . GarrettCom . com
5.1 Inspecting the Package and Product
5.2 6KPM Module Description
lock” Combo
5.2.1 6KP6-RJMST, 4@10/100Mbps RJ-45 and 2@100Mb multi-mode
FX-ST “twist
Module
and configured as 10Mb
5.2.1b 6KP4-F10ST, 4@10Mb multi-mode FX-ST “twist lock” Module
ports are ST connectors
Half-duplex by default
RJMSC is also a Combo 6 Port
mode 100Mbps fiber optic
The Magnum 6KP6
module equipped with 4 10/100Mb
5.2.3 6KP6-RJSSC 4@ 10/100Mbps RJ-45 Ports and 2@100Mbps single-mode
FX-SC-type, “snap-in” connector
mode SC-type connectors. It
The Magnum 6KP6-RJSSC
6KP8-MTRJ
“small-form-factor”
5.2.5 6KP8-MTRJ, 8 @100Mb multi-mode FX , MTRJ Small-Form-factor
8 Port@ 100Mbps Multi-Mode Fiber port
www . GarrettCom . com
5.2.6 6KP8-45MT, 4@ 10/100Mbps RJ-45 and 4@100Mb multi-mode FX
5.2.7 6KP8-MLC, 8 ports @ 100Mbps multi-mode LC connector Small
Form Factor
MTRJ Small-Form-Factor
10/100Mb 8-Port
5.2.9 6KP8-RJ45
Twisted Pair
www . GarrettCom . com
www . GarrettCom . com
www . GarrettCom . com
5.2.10b. New PoEPower Inside, model PI6KP8-45RJ MDIX, 10/100Mb 8-port
PoE LEDs Summary
PoE LEDs Summary
48VDC power in not
no power is coming to
internally connected and
5.2.12 GBIC-SXSC Gigabit fiber1000Mb, multi-mode SC Connector
5.2.12a GBPM-2OTX Two Gigabit option
www . GarrettCom . com
1@ 1000Mb Fiber SC + 2@ 100Mb SC
5.2.12b GBIC-LXSC Gigabit fiber 1000Mb, multi-mode SC Connector
5.2.13 6KM-BLNK
www . GarrettCom . com
www . GarrettCom . com
6.0 TROUBLESHOOTING
6.1 Before Calling for Assistance
www . GarrettCom . com
6.2 When Calling for Assistance
6.3 Return Material Authorization RMA Procedure
No Problem Found
6.4 Shipping and Packaging Information
APPENDIX A WARRANTY INFORMATION
Attn. Customer Service
Power Supply Internal -48VDC Option
APPENDIX B Internal DC Power Supply Options
B1.0 SPECIFICATIONS FOR MAGNUM 6K32T & 6K32TRC SWITCHES, DC POWER
Power Supply Internal 125 VDC Option Industrial Applications
Figure B4.0 -48VDC Terminal Block on Magnum 6K32T & 6K32TRC- 48VDC
B3.0 APPLICATIONS FOR DC POWERED SWITCHES
B4.0 INSTALLATION
www . GarrettCom . com
B6.0 ORDERING INFORMATION
B4.1 UL Requirements for DC-powered units
B5.0 OPERATION
6K32TRC -48VDC
Installation and User Guide 05/07
C3.0 DUAL-SOURCE OPTION, THEORY OF OPERATION
C4.0 FEATURES AND BENEFITS OF THE DUAL-SOURCE DESIGN
C5.0 INSTALLATION
www . GarrettCom . com
Example Magnum 6K32T & 6K32TRC-48VDC
C5.1 UL Requirements
C6.0 ORDERING INFORMATION
Example Magnum 6K32T & 6K32TRC-24VDC or Magnum 6K32T & 6K32TRC-125VDC