Installation and User Guide
Managed Switch
Hardware User Manual
Magnum 6K32T & 6K32TRC
Installation and User Guide
Magnum 6K32T & 6K32TRC Managed Switch Hardware
Trademarks
www . GarrettCom . com
47823Westinghouse Dr
GarrettCom, Inc
Fremont, CA
Phone 510
INSTALLATION
SPECIFICATIONS
INTRODUCTION
OPERATION
TROUBLESHOOTING
5.0 6K32T & 6K32TRC MANAGED SWITCH PORT MODULES
APPENDIX A WARRANTY INFORMATION
APPENDIX B INTERNAL DC POWER SUPPLY OPTIONS
Personal Switches, 10/100Mb
OVERVIEW
The “X-line” of configurable MiXed Media products
The Magnum Line
Performance
1.0 SPECIFICATIONS 1.1 Technical Specifications
Network Standards and Compliance
Maximum 10 Mbps Ethernet Segment Lengths
Fiber connector types supported
LC-type Small Form Factor SFF
Management Console connector
Power Supply Internal
Cooling Method
Relay Alarm Contact Optional
Fuse Required - 2Amps
Fuse Required - 3Amps
MODEL DESCRIPTION
Magnum Managed Switch
1.2 Ordering Information
Configuration Options
Modules with Gb, not using GBICs
Gigabit Options Modules using GBIC
www . GarrettCom . com
6K32T/6K32TRC PoE Modules with 48VDC Pass-Through
6K32T/6K32TRC PoE Modules with 48VDC Power Inside
NOTE For configuring in 6K Switches having AC /125VDC power input
www . GarrettCom . com
www . GarrettCom . com
www . GarrettCom . com
2.0 Introduction 2.1 Inspecting the Package and Product
www . GarrettCom . com
2.2 Product Description - Magnum 6K32TRC Managed Switch
www . GarrettCom . com
include SNMPv3, SSL/SSH, 802.1X, TACACS+, Port Security, and Tagged VLANs
www . GarrettCom . com
2.2.1a Magnum 6K32T Managed Switch Chassis
www . GarrettCom . com
2.2.2 Eight-port SFF fiber modules 6K8-MTRJ, 6K8-MLC, 100Mb fiber
Module, 6K8-RJ45 MDIX
2.2.3 Eight-Port Copper
www . GarrettCom . com
www . GarrettCom . com
2.2.3a New PoEPower Inside, model PI6KP8-45RJ MDIX, 8-port 10/100Mb
PI6KP8V-45RJ
8 Port@ 10/100Mb POE Copper ports
www . GarrettCom . com
4@RJ-45 + 2@ 100Mb ST or SC
copper and 2@10Mb fiber mm ST
2.2.5 Four-Port 10 Mb mm Fiber ST Modules
ports. The
4@ RJ-45 + 2@ 10 Mb ST
1@ 1000Mb Fiber SC + 2@ 100Mb SC
2.2.6 Gigabit 1000Mbps port modules
1@ 1000Mb Fiber SC + 4@10/ 100Mb
www . GarrettCom . com
2.2.8 Frame Buffering and Flow Control
2.2.7 Packet Prioritization, 802.1p QOS
www . GarrettCom . com
For upgrading the Magnum 6K32T & 6K32TRC Switch to its latest
2.2.9 Managed Network Software MNS-6K for Magnum 6K32T & 6K32TRC
MIBs for SNMP visit
www . GarrettCom . com
Managed switching for high performance Ethernet LANs
2.3 Features and Benefits
Switching services includes 802.1p QoS packet prioritization
Features Fiber-Built-In
Example 1 Magnum 6K32T Switch for a VLAN application
2.4 Applications
www . GarrettCom . com
Internet
www . GarrettCom . com
Data
www . GarrettCom . com
Example 3 Redundant Application 6K32TRC
6K32TRC in a Redundant application
Installation and User Guide 05/07
www . GarrettCom . com
www . GarrettCom . com
6K32TRC with IGMP-L2 mode
3.1 Locating Magnum 6K32T Switches
3.0 Installation
Figure 3.1 Location of the Magnum 6K32T’s cooling fans
www . GarrettCom . com
3.2.1 Connecting Fiber Optic ST-type, “twist-lock”
3.2 Connecting Ethernet Media
1 mm = multi-mode
2 sgl.m = single-mode
3.2.3 Connecting Single-Mode Fiber Optic
3.2.2 Connecting Fiber Optic SC-type, Snap-In
Media
IEEE Standard
Media
3.2.6 Gigabit SFP Small Form-factor Pluggable Optical Transceivers
IEEE Standard
www . GarrettCom . com
Duplex LC connector
TX Bail clasp
Side View
Front view
www . GarrettCom . com
www . GarrettCom . com
6KP4
Fiber
Speed
3.3.1 Rack-mounting for 19” RETMA racks, Magnum 6K32T & 6K32TRC’s
3.3 Table-Top or Shelf Mounting
Fig 3.3.1 Dual Side-Mountings for Magnum 6K32T & 6K32TRC units
www . GarrettCom . com
www . GarrettCom . com
3.3.2 Rack-mounting, Reverse version of the Magnum 6K32T’s
Rear Mount
3.3.2 Reverse Magnum 6K32TRC units, rack-mounted in a frame
www . GarrettCom . com
3.4 Powering the Magnum 6K32T & 6K32TRC Managed Switch
3.5.1 Preparation for Installing and Removing 6KPMs
3.5 6K32T & 6K32TRC Port Module 6KPM Installation
STOP
and will void the warranty
Figure 3.5.1a Removing front panel after the screws being removed
Step 2. Remove Chassis Cover
www . GarrettCom . com
Fig 3.5.1b Pulling out the top coved from the chassis base
Caution Be careful not to disturb the power supply
Step 3. Remove front panel face plate retaining screws
www . GarrettCom . com
Figure 3.5.1d Top View - 6KPM retaining screws hold Face Plate
3.5.2 Installing 6KPM Cards in the Magnum 6K32T & 6K32TRC
www . GarrettCom . com
www . GarrettCom . com
Fig 3.5.2d Daughter Board shown upside down with two male latch connectors
Fig. 3.5.2g Top View 6KPM Module installed inside a 6K32T
NOTE. When leaving 6KPM slots empty, always use a face plate Magnum
6K32TRC Switch
Fig.3.5.2f Securely latching up 6KPM Cards into a
Caution Be sure the power cord is unplugged
3.5.3 Removing 6KPM Cards
Figure 3.5.3a Top View
6 retaining screws shown by arrows Step 3. Remove 6KPM Card
Console DB-9 Port
Figure 3.5.3b Removing a 6KPM Card
Rear View of Magnum 6K32T
www . GarrettCom . com
3.6.1 RS-232 DB-9 Console Com port Serial port pin assignments
Signal
Description
DB-9 Console port connector
4.0 OPERATION
4.1 Switching Functionality
Filtering and Forwarding
Address Learning
4.3 Auto-Cross MDIXAuto-negotiation, for 10/100Mbps RJ-45 ports
4.2 Status LEDs
Power LED, ON when external power is applied to the unit
Full / Half duplex LED, ON when the port is running full
www . GarrettCom . com
Auto-negotiation per-port for 802.3u-compliant switches occurs when
4.4 Flow-control, IEEE 802.3x standard
5.0 Magnum 6K32T & 6K32TRC Managed Switch Port Modules
www . GarrettCom . com
5.2 6KPM Module Description
5.1 Inspecting the Package and Product
www . GarrettCom . com
FX-ST “twist
5.2.1 6KP6-RJMST, 4@10/100Mbps RJ-45 and 2@100Mb multi-mode
lock” Combo
Module
ports are ST connectors
5.2.1b 6KP4-F10ST, 4@10Mb multi-mode FX-ST “twist lock” Module
and configured as 10Mb
Half-duplex by default
The Magnum 6KP6
mode 100Mbps fiber optic
RJMSC is also a Combo 6 Port
module equipped with 4 10/100Mb
mode SC-type connectors. It
FX-SC-type, “snap-in” connector
5.2.3 6KP6-RJSSC 4@ 10/100Mbps RJ-45 Ports and 2@100Mbps single-mode
The Magnum 6KP6-RJSSC
5.2.5 6KP8-MTRJ, 8 @100Mb multi-mode FX , MTRJ Small-Form-factor
“small-form-factor”
6KP8-MTRJ
8 Port@ 100Mbps Multi-Mode Fiber port
www . GarrettCom . com
Form Factor
5.2.7 6KP8-MLC, 8 ports @ 100Mbps multi-mode LC connector Small
5.2.6 6KP8-45MT, 4@ 10/100Mbps RJ-45 and 4@100Mb multi-mode FX
MTRJ Small-Form-Factor
Twisted Pair
5.2.9 6KP8-RJ45
10/100Mb 8-Port
www . GarrettCom . com
www . GarrettCom . com
PoE LEDs Summary
5.2.10b. New PoEPower Inside, model PI6KP8-45RJ MDIX, 10/100Mb 8-port
www . GarrettCom . com
no power is coming to
48VDC power in not
PoE LEDs Summary
internally connected and
5.2.12 GBIC-SXSC Gigabit fiber1000Mb, multi-mode SC Connector
www . GarrettCom . com
5.2.12a GBPM-2OTX Two Gigabit option
5.2.13 6KM-BLNK
5.2.12b GBIC-LXSC Gigabit fiber 1000Mb, multi-mode SC Connector
1@ 1000Mb Fiber SC + 2@ 100Mb SC
www . GarrettCom . com
6.1 Before Calling for Assistance
6.0 TROUBLESHOOTING
www . GarrettCom . com
6.3 Return Material Authorization RMA Procedure
6.2 When Calling for Assistance
www . GarrettCom . com
APPENDIX A WARRANTY INFORMATION
6.4 Shipping and Packaging Information
No Problem Found
Attn. Customer Service
B1.0 SPECIFICATIONS FOR MAGNUM 6K32T & 6K32TRC SWITCHES, DC POWER
APPENDIX B Internal DC Power Supply Options
Power Supply Internal -48VDC Option
Power Supply Internal 125 VDC Option Industrial Applications
B4.0 INSTALLATION
B3.0 APPLICATIONS FOR DC POWERED SWITCHES
Figure B4.0 -48VDC Terminal Block on Magnum 6K32T & 6K32TRC- 48VDC
www . GarrettCom . com
B5.0 OPERATION
B4.1 UL Requirements for DC-powered units
B6.0 ORDERING INFORMATION
6K32TRC -48VDC
Installation and User Guide 05/07
C5.0 INSTALLATION
C4.0 FEATURES AND BENEFITS OF THE DUAL-SOURCE DESIGN
C3.0 DUAL-SOURCE OPTION, THEORY OF OPERATION
www . GarrettCom . com
C6.0 ORDERING INFORMATION
C5.1 UL Requirements
Example Magnum 6K32T & 6K32TRC-48VDC
Example Magnum 6K32T & 6K32TRC-24VDC or Magnum 6K32T & 6K32TRC-125VDC