Managed Switch
Installation and User Guide
Hardware User Manual
Magnum 6K32T & 6K32TRC
Magnum 6K32T & 6K32TRC Managed Switch Hardware
Installation and User Guide
Trademarks
www . GarrettCom . com
GarrettCom, Inc
47823Westinghouse Dr
Fremont, CA
Phone 510
SPECIFICATIONS
INSTALLATION
INTRODUCTION
OPERATION
5.0 6K32T & 6K32TRC MANAGED SWITCH PORT MODULES
TROUBLESHOOTING
APPENDIX A WARRANTY INFORMATION
APPENDIX B INTERNAL DC POWER SUPPLY OPTIONS
OVERVIEW
Personal Switches, 10/100Mb
The “X-line” of configurable MiXed Media products
The Magnum Line
1.0 SPECIFICATIONS 1.1 Technical Specifications
Performance
Network Standards and Compliance
Maximum 10 Mbps Ethernet Segment Lengths
LC-type Small Form Factor SFF
Fiber connector types supported
Management Console connector
Power Supply Internal
Relay Alarm Contact Optional
Cooling Method
Fuse Required - 2Amps
Fuse Required - 3Amps
Magnum Managed Switch
MODEL DESCRIPTION
1.2 Ordering Information
Configuration Options
Modules with Gb, not using GBICs
Gigabit Options Modules using GBIC
www . GarrettCom . com
6K32T/6K32TRC PoE Modules with 48VDC Power Inside
6K32T/6K32TRC PoE Modules with 48VDC Pass-Through
NOTE For configuring in 6K Switches having AC /125VDC power input
www . GarrettCom . com
www . GarrettCom . com
2.0 Introduction 2.1 Inspecting the Package and Product
www . GarrettCom . com
2.2 Product Description - Magnum 6K32TRC Managed Switch
www . GarrettCom . com
include SNMPv3, SSL/SSH, 802.1X, TACACS+, Port Security, and Tagged VLANs
www . GarrettCom . com
2.2.1a Magnum 6K32T Managed Switch Chassis
www . GarrettCom . com
2.2.2 Eight-port SFF fiber modules 6K8-MTRJ, 6K8-MLC, 100Mb fiber
www . GarrettCom . com
Module, 6K8-RJ45 MDIX
2.2.3 Eight-Port Copper
www . GarrettCom . com
2.2.3a New PoEPower Inside, model PI6KP8-45RJ MDIX, 8-port 10/100Mb
www . GarrettCom . com
PI6KP8V-45RJ
8 Port@ 10/100Mb POE Copper ports
4@RJ-45 + 2@ 100Mb ST or SC
www . GarrettCom . com
2.2.5 Four-Port 10 Mb mm Fiber ST Modules
copper and 2@10Mb fiber mm ST
ports. The
4@ RJ-45 + 2@ 10 Mb ST
2.2.6 Gigabit 1000Mbps port modules
1@ 1000Mb Fiber SC + 2@ 100Mb SC
1@ 1000Mb Fiber SC + 4@10/ 100Mb
www . GarrettCom . com
2.2.8 Frame Buffering and Flow Control
2.2.7 Packet Prioritization, 802.1p QOS
www . GarrettCom . com
2.2.9 Managed Network Software MNS-6K for Magnum 6K32T & 6K32TRC
For upgrading the Magnum 6K32T & 6K32TRC Switch to its latest
MIBs for SNMP visit
www . GarrettCom . com
2.3 Features and Benefits
Managed switching for high performance Ethernet LANs
Switching services includes 802.1p QoS packet prioritization
Features Fiber-Built-In
Example 1 Magnum 6K32T Switch for a VLAN application
2.4 Applications
www . GarrettCom . com
Internet
www . GarrettCom . com
Data
Example 3 Redundant Application 6K32TRC
www . GarrettCom . com
6K32TRC in a Redundant application
Installation and User Guide 05/07
www . GarrettCom . com
6K32TRC with IGMP-L2 mode
www . GarrettCom . com
3.0 Installation
3.1 Locating Magnum 6K32T Switches
Figure 3.1 Location of the Magnum 6K32T’s cooling fans
www . GarrettCom . com
3.2 Connecting Ethernet Media
3.2.1 Connecting Fiber Optic ST-type, “twist-lock”
1 mm = multi-mode
2 sgl.m = single-mode
3.2.2 Connecting Fiber Optic SC-type, Snap-In
3.2.3 Connecting Single-Mode Fiber Optic
Media
IEEE Standard
3.2.6 Gigabit SFP Small Form-factor Pluggable Optical Transceivers
Media
IEEE Standard
www . GarrettCom . com
TX Bail clasp
Duplex LC connector
Side View
Front view
www . GarrettCom . com
6KP4
www . GarrettCom . com
Fiber
Speed
3.3 Table-Top or Shelf Mounting
3.3.1 Rack-mounting for 19” RETMA racks, Magnum 6K32T & 6K32TRC’s
Fig 3.3.1 Dual Side-Mountings for Magnum 6K32T & 6K32TRC units
www . GarrettCom . com
3.3.2 Rack-mounting, Reverse version of the Magnum 6K32T’s
www . GarrettCom . com
Rear Mount
3.3.2 Reverse Magnum 6K32TRC units, rack-mounted in a frame
3.4 Powering the Magnum 6K32T & 6K32TRC Managed Switch
www . GarrettCom . com
3.5 6K32T & 6K32TRC Port Module 6KPM Installation
3.5.1 Preparation for Installing and Removing 6KPMs
STOP
and will void the warranty
Figure 3.5.1a Removing front panel after the screws being removed
Step 2. Remove Chassis Cover
www . GarrettCom . com
Caution Be careful not to disturb the power supply
Fig 3.5.1b Pulling out the top coved from the chassis base
Step 3. Remove front panel face plate retaining screws
www . GarrettCom . com
Figure 3.5.1d Top View - 6KPM retaining screws hold Face Plate
3.5.2 Installing 6KPM Cards in the Magnum 6K32T & 6K32TRC
www . GarrettCom . com
Fig 3.5.2d Daughter Board shown upside down with two male latch connectors
www . GarrettCom . com
NOTE. When leaving 6KPM slots empty, always use a face plate Magnum
Fig. 3.5.2g Top View 6KPM Module installed inside a 6K32T
6K32TRC Switch
Fig.3.5.2f Securely latching up 6KPM Cards into a
3.5.3 Removing 6KPM Cards
Caution Be sure the power cord is unplugged
Figure 3.5.3a Top View
6 retaining screws shown by arrows Step 3. Remove 6KPM Card
Figure 3.5.3b Removing a 6KPM Card
Console DB-9 Port
Rear View of Magnum 6K32T
www . GarrettCom . com
Signal
3.6.1 RS-232 DB-9 Console Com port Serial port pin assignments
Description
DB-9 Console port connector
4.1 Switching Functionality
4.0 OPERATION
Filtering and Forwarding
Address Learning
4.2 Status LEDs
4.3 Auto-Cross MDIXAuto-negotiation, for 10/100Mbps RJ-45 ports
Power LED, ON when external power is applied to the unit
Full / Half duplex LED, ON when the port is running full
Auto-negotiation per-port for 802.3u-compliant switches occurs when
www . GarrettCom . com
4.4 Flow-control, IEEE 802.3x standard
5.0 Magnum 6K32T & 6K32TRC Managed Switch Port Modules
www . GarrettCom . com
5.2 6KPM Module Description
5.1 Inspecting the Package and Product
www . GarrettCom . com
5.2.1 6KP6-RJMST, 4@10/100Mbps RJ-45 and 2@100Mb multi-mode
FX-ST “twist
lock” Combo
Module
5.2.1b 6KP4-F10ST, 4@10Mb multi-mode FX-ST “twist lock” Module
ports are ST connectors
and configured as 10Mb
Half-duplex by default
mode 100Mbps fiber optic
The Magnum 6KP6
RJMSC is also a Combo 6 Port
module equipped with 4 10/100Mb
FX-SC-type, “snap-in” connector
mode SC-type connectors. It
5.2.3 6KP6-RJSSC 4@ 10/100Mbps RJ-45 Ports and 2@100Mbps single-mode
The Magnum 6KP6-RJSSC
“small-form-factor”
5.2.5 6KP8-MTRJ, 8 @100Mb multi-mode FX , MTRJ Small-Form-factor
6KP8-MTRJ
8 Port@ 100Mbps Multi-Mode Fiber port
www . GarrettCom . com
5.2.7 6KP8-MLC, 8 ports @ 100Mbps multi-mode LC connector Small
Form Factor
5.2.6 6KP8-45MT, 4@ 10/100Mbps RJ-45 and 4@100Mb multi-mode FX
MTRJ Small-Form-Factor
5.2.9 6KP8-RJ45
Twisted Pair
10/100Mb 8-Port
www . GarrettCom . com
www . GarrettCom . com
PoE LEDs Summary
5.2.10b. New PoEPower Inside, model PI6KP8-45RJ MDIX, 10/100Mb 8-port
www . GarrettCom . com
48VDC power in not
no power is coming to
PoE LEDs Summary
internally connected and
5.2.12 GBIC-SXSC Gigabit fiber1000Mb, multi-mode SC Connector
5.2.12a GBPM-2OTX Two Gigabit option
www . GarrettCom . com
5.2.12b GBIC-LXSC Gigabit fiber 1000Mb, multi-mode SC Connector
5.2.13 6KM-BLNK
1@ 1000Mb Fiber SC + 2@ 100Mb SC
www . GarrettCom . com
6.1 Before Calling for Assistance
6.0 TROUBLESHOOTING
www . GarrettCom . com
6.3 Return Material Authorization RMA Procedure
6.2 When Calling for Assistance
www . GarrettCom . com
6.4 Shipping and Packaging Information
APPENDIX A WARRANTY INFORMATION
No Problem Found
Attn. Customer Service
APPENDIX B Internal DC Power Supply Options
B1.0 SPECIFICATIONS FOR MAGNUM 6K32T & 6K32TRC SWITCHES, DC POWER
Power Supply Internal -48VDC Option
Power Supply Internal 125 VDC Option Industrial Applications
B3.0 APPLICATIONS FOR DC POWERED SWITCHES
B4.0 INSTALLATION
Figure B4.0 -48VDC Terminal Block on Magnum 6K32T & 6K32TRC- 48VDC
www . GarrettCom . com
B4.1 UL Requirements for DC-powered units
B5.0 OPERATION
B6.0 ORDERING INFORMATION
6K32TRC -48VDC
Installation and User Guide 05/07
C4.0 FEATURES AND BENEFITS OF THE DUAL-SOURCE DESIGN
C5.0 INSTALLATION
C3.0 DUAL-SOURCE OPTION, THEORY OF OPERATION
www . GarrettCom . com
C5.1 UL Requirements
C6.0 ORDERING INFORMATION
Example Magnum 6K32T & 6K32TRC-48VDC
Example Magnum 6K32T & 6K32TRC-24VDC or Magnum 6K32T & 6K32TRC-125VDC