Technical Service Guide | GE PDE9900 instruction

GE Consumer & Industrial

Technical Service Guide

February 2006

GE ProﬁleTM

Dishwasher

PDW8900 Series

PDW9700 Series

PDW9900 Series

31-9137

GE Appliances

General Electric Company

Louisville, Kentucky 40225

Image 1

GE PDE9900 manual Technical Service Guide

Contents

Technical Service Guide Important Safety Notice Table of Contents W 9 9 8 0 L 0 0 S S NomenclatureModel Number Serial Number Introduction PDW8900 Series Control Features Selections Enhancements Start PDW8900 Series Shown Inside Cabinet View Component Locator ViewsLeft Side View PDW8900 Series Shown Door View PDW8900 Series Shown Bottom View PDW9000 Series ShownFront of Dishwasher Rear of Dishwasher Door Panel PDW9700 Series and PDW9900 Series Dishwasher ComponentsPDW8900 Series Keypad Assembly PDW9700 Series and PDW9900 Series SmartDispenseTM Calibration Water Hardness Test and Calibration Test Water HardnessWater Hardness Test Strip Indication Front Mount Control PDW8900 Detergent Reservoir SmartDispenseTMTo remove the reservoir Detergent Level Sensor Approximate Detergent Use Positive Displacement PumpTo remove the pump Customer Purge of the Bulk Dispenser Tank When to Purge the Bulk Dispenser TankConsumer Purge Cycle Detergent/Rinse Module Door Interlock Switchﬁrst time the module is activated Removal and Replacement Using the Dishwasher with the Upper Rack RemovedMiddle Spray Arm Main Conduit Upper Spray ArmFill Funnel Lower Spray Arm, Fine Filter, and Inlet Cover Heating Element Test Turbidity SensorCalibrating the Turbidity Sensor Drain System Smart Fill System Water Valve Test Water Valve and Flood Switch Wash Cycles Demo Mode Control Module Board Control Module Active Vent Normal Wash Cycle Single Rack WashTM Wax Motor and Magnet Circulation Pump and Motor Door Spring Installation Description Time Service Mode Entering Factory Test Mode Factory Test Mode Verify operation after Schematics and Strip Circuits PDW9900 Series PDW9700 Series For The Period GE Will Replace Warranty for 2005 Product For The Period GE Will Replace Warranty for 2006 and Later Product