Manuals / GSW / Household Appliance / Water Heater

GSW 5065 manual

Models: 5065

1 29

Download 29 pages 31.31 Kb

Page 2

Image 2

This page intentionally left blank. May be used for notes or to record other installation information.

– 2 –

Page 2

Image 2

Contents

FOR YOUR SAFETY POWER VENTED WATER HEATERINSTALLATION AND OPERATING INSTRUCTIONS FLAMMABLE VAPOUR IGNITION RESISTANTPage TABLE OF CONTENTS Consumer Responsibilities This is the safety alert symbolI INTRODUCTION For Installations in the United States II SAFETYFor Installations in Canada Safety Warning Flammable VapoursRelief Valve Requirements T&P IIIINSTALLATION Unpacking the Water HeaterExcessive Weight Hazard Location RequirementsGas Supply Clearances and AccessibilityInstall a gas supply shut-offvalve Explosion HazardGas Leak Testing Gas PressureConfined Space Air Requirements for Canadian InstallationsAir Requirements “an unconfined space” or “a confined space.”Burn Hazard U.S. Installationsb Basement installation, equipment located in Do not touch ventUse only in well-ventilatedareas VentingUse of Solvent Cement and Primer Do not use near flame or open fireVertical Vent Terminal Installation F F FHorizontal Vent Terminal Installations Code ANSI Z223.1 NFPA 54 U.S.A. and local codes Vent Pipe InstallationCode CAN/CSA-B149.1 Canada, or National Fuel Gas Rubber Coupling Connection Vent Pipe RunsVent Pipe Connection to Blower Water Supply Piping Installationand pressure relief temperatureIf the valveent at the electric connections of the gas When the unit is plugged in, 120VAC is presElectrical Supply control/thermostatReplace all parts and panels before operating Disconnect power before servicingElectrical Shock Hazard Figure 22 Robertshaw Wiring Diagram - ControlGas Supply and Piping Installation ChecklistWater Heater Location Vent Pipe SystemPOUR VOTRE SÉCURITÉ, LISEZ AVANT FOR YOUR SAFETY READ BEFOREIV LIGHTING & OPERATING INSTRUCTIONS OPERATINGWhen heater is ready to be put into service VOPERATION First LightingGas Control/Thermostat What to Do If You Smell GasRisk of scalding Temperature RegulationFlammable Vapour Sensor SYSTEM STATUS CODESunobstructed Water Heater OperationKeep the area around the heater clear and Emergency Shut DownDraining and Flushing Routine Preventative MaintenanceVI MAINTENANCE Venting System and BlowerDo not plug valve Do not remove valve Temperature and Pressure Relief ValveReplacement Parts VII COMBO HEATINGInstallation POSSIBLE CAUSES VIII TROUBLESHOOTING GUIDE Robertshaw 2000WDERSYMPTOM CORRECTIVE ACTIONIX PARTS REFERENCE ILLUSTRATION Items not supplied with the water heater~ Certificate of Warranty ~ Warranty Code