Section 1 – General Information
Recreational Vehicle Generators
Figure 1.1 – Connection for 120 Volts Only |
|
| NOTE: | |||||||||||
|
|
|
|
|
|
|
|
|
| Using unleaded gasoline contributes to longer | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| engine valve life by reducing lead and carbon | ||||
|
|
|
|
|
|
|
|
|
| deposits. | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| The manufacturer does not recommend using | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| any gasoline containing alcohol (such as “gaso- | ||||
|
|
|
|
|
|
|
|
|
| hol”). If using any gasoline containing alcohol, it | ||||
|
|
|
|
|
|
|
|
|
| must not contain more than 10 percent ethanol, | ||||
|
|
|
|
|
|
|
|
|
| and it must be removed from the generator dur- | ||||
|
|
|
|
|
|
|
|
|
| ing storage. Do NOT use any gasoline containing | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| methanol. If using gasoline with alcohol, inspect | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| more frequently for fuel leaks and other abnor- | ||||
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| malities. |
Figure 1.2 - Connection for 120/240 Volts
1.6.2 ENGINE OIL REQUIREMENTS
CB1
T1
RED
T2
Use only high quality detergent oil rated with American Petroleum Institued (API) Classification SF, SG, SH or SJ. The recommended oil viscosity weights include the following:
• During summer months (40 deg. F and higher), |
SAE 30 or SAE |
• During winter months (40 deg. F to |
WHITE
CB2 T3
BLACK
STATOR WINDINGS GROUNDED NEUTRAL
1.6SPECIFICATIONS
1.6.1 FUEL REQUIREMENTS (GASOLINE)
This generator is equipped with a gasoline fuel system as standard equipment. Specific installations may provide either a separate fuel tank for the generator, or the generator may “share” the vehicle engine’s fuel tank.
1.6.1.1 Fuel Consumption (gph)
| Model | 10% Load | 50% Load | 100% Load |
|
| QuietPact 55G | 0.51 | 0.73 | 0.97 |
|
| QuietPact 65G | 0.51 | 0.76 | 1.07 |
|
| QuietPact 75G | 0.51 | 0.80 | 1.28 |
|
NOTE
Some installations using a “shared” fuel tank may have a generator fuel pickup tube that is shorter than the vehicle engine’s pickup tube. Such an arrangement causes the generator engine to “run out of gas” while adequate fuel for the vehicle remains in the tank.
To reduce lead and carbon deposits use high qual- ity UNLEADED gasoline with the generator. Leaded REGULAR grade gasoline is an acceptable substitute.
SAE |
• DO NOT USE SAE |
Crankcase and oil filter capacity is approximately 1.8 L or 1.9 U.S. quarts. DO NOT use special additives. See Sections 3.1 and 3.2 for oil level check and filling procedures.
1.6.3 ENGINE SPECIFICATIONS
Type of Engine | ||
Cooling Method | ||
Rated Horsepower | 27 at 3600 rpm | |
Displacement | 760cc | |
Compression Ratio | 8.6 to 1 | |
Cylinder Block | Aluminum w/Cast Iron Sleeve | |
Type of Governor | Mechanical, Fixed Speed | |
Engine Governor Speed |
|
|
QUIETPACT 55 | 2200 rpm | |
QUIETPACT 65/75 | 2571 rpm | |
Air Cleaner | Paper Element w/Foam Precleaner | |
Starter | ||
Ignition System | ||
Recommended Spark Plug |
| |
Champion | RC14YC | |
AC | R45S | |
Fram Autolite | 65 | |
Spark Plug Gap | 0.030 inch (0.8 mm) | |
Recommended Min. Battery | .......... 400 Cold Cranking Amps |
6