Service Parts List, Lpk-Dxv | Heat & Glo LifeStyle ST-36TRB-IPI

C. Service Parts List

ST-36TRB-IPI,PIER-36TRB-IPI, LCOR-36TRB-IPI, RCOR-36TRB-IPI



IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement				Stocked
parts for your appliance please provide model number and serial number. All parts listed				Stocked
in this manual may be ordered from an authorized dealer.				at Depot
ITEM	DESCRIPTION	COMMENTS	PART NUMBER
	Exhaust Bafﬂe		385-105
	Flue Restrictor		385-128
	Glass Latch Assembly	Pkg of 2	33858/2	Y
	Gasket Assembly
	Contains Vent, Seal Cap, Burner Neck, Shutter Bracket		2128-081
	and Valve Plate Gaskets

	Lava Rock		2005-790
	Mineral Wool		050-721
	Touch Up Paint		TUP-GBK-12

Conversion Kit NG	NGK-MS36	Y
Conversion Kit LP	LPK-MS36	Y
Pilot Oriﬁce NG	593-528	Y
Pilot Oriﬁce LP	593-527	Y
Regulator NG	NGK-DXV	Y
Regulator LP	LPK-DXV	Y

Heat & Glo • ST-36TRB-IPI, PIER-36TRB-IPI, LCOR-36TRB-IPI, RCOR-36TRB-IPI • 2128-900 Rev. H • 8/11

Page 81

Image 81

Heat & Glo LifeStyle ST-36TRB-IPI owner manual Service Parts List, Lpk-Dxv

Contents

What to do if you smell gas HOT SurfacesHot glass will cause burns Homeowner Reference Information Congratulations User Guide Table of Contents Troubleshooting Appliance SetupFinishing Reference Materials Limited Lifetime Warranty  B. Limited Lifetime Warranty Warranty Conditions Listing and Code Approvals Requirements for the Commonwealth of Massachusetts Installation of Carbon Monoxide Detectors Gas Fireplace Safety Operating Instructions User GuideYour Fireplace Fixed Glass Assembly Blower InstallationRemote Controls, Wall Controls and Wall Switches Blower Kit optional Final inspection by Lighting Instructions IPIWhat to do if YOU Smell GAS GAS Valve Frequently Asked Questions Issue SolutionsAfter Fireplace is Lit Maintenance Tasks-Homeowner Maintenance and ServiceGlass Cleaning Remote Control Gasket Seal and Glass Assembly Inspection Maintenance Tasks-Qualiﬁed Service TechnicianVenting Logs IPI Pilot Flame Patterns Burner Ignition and Operation Typical Appliance System Getting Started Tools and Supplies Needed Design and Installation ConsiderationsInspect Appliance and Components Any such action may cause a ﬁre hazard Selecting Appliance Location Framing and Clearances Clearances Constructing the Appliance Chase RCOR-36TRB-IPI PIER/LCOR/RCOR Combustible Mantel Mantel and Wall Projections See-Through Combustible MantelSee-Through Non-Combustible Mantel PIER/LCOR/RCOR Non-Combustible Mantel TOP View Termination Locations Vent Termination Minimum ClearancesGas, Wood or Fuel Oil Termination Cap Covered Alcove Applications Approved Pipe Vent Information and DiagramsVent Table Key Use of Elbows To SLP series vent pipe, if desired Vent DiagramsTop Vent-Horizontal Termination-Two 45 Elbows Elbow on rear vent appliances Two Elbows Top Vent Horizontal Termination One ElbowV1 Minimum H1 Maximum V1 Minimum H1 + H2 Maximum Top Vent Horizontal Termination Three Elbows 152 mm305 mm Exhaust restrictor Instructions 15 ft 20 ft 25 ft 30 ft 35 ft 40 ft 45 ft 50 ft 55 ft Break Here Maximum + V 2 Minimum Two Elbows Three Elbows12 ft 18 ft V1 + V2 + H1 = 50 ft 15.2 m Maximum H1+ H2 V1 + V2 Minimum H1+ H2 MaximumPage Rear Vent Horizontal Termination Two Elbows H1 Maximum V1 Minimum H2 Maximum H1+ H2 MaximumH1 Maximum V1 Minimum H2+ H3 H1+ H2+ H3 V1 Minimum H1 Maximum Rear Vent Vertical Termination One ElbowV1+ H1 = 40 ft 12.2 m Maximum Minimum + H 2 Maximum Rear Vent Vertical Termination Three Elbows H1 Maximum V1 Minimum H1+ H2 MaximumV1 Minimum H1+ H2+ H3 Maximum Vent Clearances and Framing Pipe Clearances to CombustiblesContinue Adding Vent Components Combustible Wall Penetration Wall Penetration FramingNon-Combustible Wall Penetration Correct Pipe DVP SLP Vertical Penetration Framing Install Attic Insulation Shield Flat Ceiling InstallationVaulted Ceiling Installation Appliance Preparation Top VentProceed to . C Cut the metal retaining band Rear Vent Attach Nailing Tab to Front Corner of Unit Securing and Leveling the Appliance Attach Vent to the Firebox Assembly Installing Vent Pipe DVP and SLP PipeAssemble Vent Sections DVP Pipe Only Assemble Pipe Sections DVP Pipe Only Assemble Slip Sections Assemble Vent Sections SLP Pipe Only Disassemble Vent Sections Secure the Vent Sections Install Decorative Ceiling Components SLP only Assemble and Install Storm Collar Install Metal Roof Flashing Install Decorative Wall Components SLP only Install Vertical Termination CapHeat Shield Requirements for Horizontal Termination Important Notice Heat shields may not be ﬁeld constructed DVP-HPC1 DVP-HPC2 Install Horizontal Termination Cap DVP and SLP Pipe Fuel Conversion Gas InformationGas Pressure Gas Connection Wiring Requirements Optional Accessories RequirementsElectrical Information Intelliﬁre Ignition Wiring Diagram with Remote Receiver Wall Switch Installation for Fan Optional Junction Box Installation To install the Splatter Guard FinishingSplatter Guard To Remove the Splatter Guard To Close the Lower Access Panel PIER/LCOR/RCOR Mantel Projection Mantel and Wall Projections See-Through Mantel Projection Facing Material Finishing MaterialStop ﬁnishing material ﬂush with opening Finishing material between 1 and 2 inches thick Finishing materials over 1 inch thick Elevated Hearth Systems Appliance Setup 2128-935 Install the Log Assembly Indentations Install Trim Kits and Surrounds Air Shutter SettingAir Shutter Settings Troubleshooting Symptom Possible Cause Corrective ActionIntelliﬁre Ignition System ﬂame rectiﬁcation has Appliance Dimension Diagram Reference MaterialsLocation Inches Millimeters Pier Dimensions Electrical Access GAS Line Left View Front View Right View 40-1/2 Left View Front View Electrical Access GAS Line Right View24-1/2 33-1/2 DVP-AS2 Vent Components Diagrams Horizontal Termination Cap DVP-TRAP BEK DVP-BEK2 RF6M RF12MDVP-TRAPFL COOL-ADD DVP-TV Power Vent Inline Optional Wire HarnessPVI-SLP SLP-LPC Ceiling Firestop ElbowSupport SLP-WS SLP-SNKD SLP-CCS-BK DVP-FBHTSLP-DCF-BK Log Set Assembly Service PartsAt Depot See Through Direct Vent Gas Fireplace Pier Direct Vent Fireplace PIER-36TRB-IPI Left Corner Direct Vent Fireplace LCOR-36TRB-IPI Right Corner Direct Vent Fireplace RCOR-36TRB-IPI Stocked #15 Valve Assembly LPK-DXV Service Parts List Contact Information

C. Service Parts List

Stocked

at Depot

DESCRIPTION

LPK-DXV